《SV型静态混合器数值模拟湍流模型选择.doc》由会员分享,可在线阅读,更多相关《SV型静态混合器数值模拟湍流模型选择.doc(2页珍藏版)》请在三一文库上搜索。
1、龙源期刊网 SV 型静态混合器数值模拟湍流模型选择 作者:王泽斌 宋涛 张春梅 来源:当代化工 2016 年第 01 期摘 要:利用 Fluent 软件分别采用标准 模型、 Realizable 模型和 RNG 型对 SV 型静态混合 器的湍流流速场进行了模拟,得到时均速度、湍动能和湍流强度,与实验值进行对比,计算了 数值计算结果与实验值之间的标准差。结果表明:三种数值模型对时均流速的预测差别不大, 而对于湍动能和湍流强度的预测, Realizable 模型的标准差是其它两个模型的50%左右,是最适合 SV 型静态混合器的湍流模型。关 键 词: SV 型静态混合器;数值模拟;湍流模型;中图分类
2、号: TQ 051.7 文献标识码: A 文章编号: 1671-0460(2016) 01-0166-04The Turbulence Model Choice of SV Static MixerWANG Ze-bin1 , SONG Tao2, ZHANG Chun-mei1( 1. Shenyang University of Chemical Technology , Liaoning Shenyang 110142 ,China ;2. Elion Chemical Industry Co. , ltd , Inner Mongolia Ordos 014300 , China )A
3、bstract : Based on Fluent, Realizable model , RNG model and the standard model were used to calculate the turb Based on Fluent, Realizable model , RNG model and the standard model were used to calculate the turbulent velocity field of SV static mixer. The time-averaged velocity , turbulent kinetic e
4、nergy and turbulence intensity were achieved and compared with the experimental value ; the standard deviation between the results of numerical calculation and the experimental values was calculated. The results show that : there is little difference among three forecasts of the time-averaged veloci
5、ty ; while for the forecasts of turbulent kinetic energy and turbulence intensity , the standard deviation of Realizable model is about 50% of the other two models. So , it is the most suitable turbulence model for SV static mixer numerical simulation.Key words : SV static mixer ; Numerical simulati
6、on ; Turbulence model静态混合器( Static Mixer ) 是一种新型高效的混合设备 1 ,通过固定在流体通道内的混 合元件使流体达到良好的分散和充分混合的目的, 近年来在工业中得到了广泛的应用 2,3 。 随着计算流体技术的发展,许多科学工作者 4-6 用数值模拟的方式研究了多种静态混合器,但 是它们针对的静态混合器多是简单结构的,并没有太多研究是关于 SV 型静态混合器的。 Lang 等7 预测了 SV 型静态混合器中的湍流流动,采用 TASCflow 软件计算浓度方程,并给出温度 分布,最后用实验验证。南京工业大学的樊水冲 8等人模拟了 SV 型静态混合器内的流场,