《e链条拉伸万能试验机的原理图及链条抗拉强度试验机的安装方案.doc》由会员分享，可在线阅读，更多相关《e链条拉伸万能试验机的原理图及链条抗拉强度试验机的安装方案.doc（53页珍藏版）》请在三一文库上搜索。
1、链条拉伸液压万能试验机一、简介铂鉴牌链条拉伸万能试验机适应标准：GB/T3159-2008液压式万能试验机，GB/T228-2002金属材料室温拉伸试验方法等。铂鉴牌链条抗拉强度试验机利用液压加荷，数显控制仪显示试验结果,操作方便，试验读数准确可靠，用于各种金属材料的拉伸、压缩、弯曲及剪切试验，亦可用作塑料、混凝土、水泥等非金属材料的压缩试验，增加简单附件，可完成胶带链条，钢丝绳、电焊条、瓦及构件的多种性能试验。本数显式液压万能试验机采用油缸下置式、高度低、重量轻，尤其适用于工程施工部门。1、在测力计外壳内装有柱塞式高压油泵，由电动机带动，运转时动作平稳及音响正常。拉伸空间位于主机的上方，压缩
2、、弯曲试验空间位于主机下方下横梁和工作台之间。2、下横梁升降采用电机经减速器、链传动机构、丝杠副传动，实现拉伸、压缩空间的调整。3、铂鉴牌链条抗拉强度试验机的液压系统主要由测力计外面油阀手柄控制，操作方便保证安全。4、本机有加荷速度显示功能，能实现试样要求的加荷速度，操纵部分及指示部分高度适当，便于试验者进行操作与观察。5、 本液压万能试验机预留有联网和升级接口,根据用户需要可升级为伺服式,是更新换代的理想产品。二、方案描述1、主机 主机采用油缸下置式主机，拉伸空间位于主机的上方，压缩、弯曲试验空间位于主机上方下横梁和工作台之间。2、传动系统下横梁升降电机经减速器、链传动机构、丝杠传动，实现拉
3、伸、压缩空间的调整3、液压系统铂鉴牌链条拉伸万能试验机液压原理如图所示，为负载适应型进油节流调速系统，手动阀控制试验进程。油箱内的液压油通过电机带动高压齿轮泵进入油路，流经单向阀、10高压滤油器、压差阀组、送油阀，进入油缸。通过手动控制送油阀的开口大小，从而控制进入油缸的流量，满足加载的要求。试验完成后，打开回油阀卸荷并使油缸返回。 （液压原理图）三、技术参数1、最大试验力kN： 3002、试验力测量范围kN： 63003、试验力示值相对误差：示值的1%4、试验力分辨率： 0.01kN5、最大拉伸试验空间mm： 5506、最大压缩空间mm： 5007、活塞行程mm： 2008、圆试样钳口夹持直
4、径mm：6-269、扁试样钳口夹持厚度mm： 0-1510、扁试样最大夹持宽度mm： 7011、压盘尺寸mm：160mm12、弯曲试验两点间最大距离mm： 35013、弯曲支滚宽度mm： 12014、弯曲支滚直径mm：3015、活塞最大移动速度mm/min： 5016、夹紧方式：自动/手动加紧 （两款供您选择）17、主机外形尺寸mm：约800580210018、测力柜外形尺寸mm ： 约550550120019、重量Kg： 约2100四、配置清单类型序号名称规格数量备注产品1BJWE-S300B数显式液压万能试验机300KN1台2数显控制器1只文件1使用说明书1份2合格证1份3装箱单1份附件1
5、扁试样钳口（mm）0154件在主机上2圆试样钳口（mm）61313268件3弯曲支座（mm）301401支装在机器上4弯曲压头（mm）301401支装在附件箱内5球面座板（mm）1206下压板（mm）160*1607上压板（mm）160*160装在机器上五、设备安装方案、计划、安装及培训货物安装方案及计划1、 需方提前准备好设备安装场地；2、 需方提前打好地基；3、 需方提前安排好工作2-3个工作人员，协助供方安装设备；4、 供方组织1-2人，与需方协调后，去需方公司进行安装；货物安装、施工组织机构及人员情况1、 供需双方协商后，供方在需方的协助下，共同安装设备；2、 供方1-2人，需方2-3
6、人；培训人数需方1-5人培训时间安装、调试完毕后进行培训培训地点需方单位培训内容设备的操作，以及控制软件的操作与使用培训目的能够熟练操作本试验机，按要求独立完成试验过程六、环境与工作条件1、室温10-35范围内;相对湿度不大于80%；2、周围无振动、无腐蚀性介质和无较强电磁场干扰的清洁环境中；3、电源电压的波动范围应在额定电压的土10%以内；4、在稳固的基础上正确安装。以上技术资料是济南铂鉴测试技术有限公司专业为您提供的！（英文版 ） Two regulations promulgated for implementation is in the party in power for a lo
7、ng time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a pos
8、itive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the
9、 bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in th
10、e party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment
11、 to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experie
12、nce, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects th
13、e partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulatio
14、ns of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet th
15、e actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and disciplin
16、e law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revisi
17、on, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law
18、, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and se
19、rious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousne
20、ss in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jin
21、ping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months be
22、gin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respe
23、ctively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars an
24、d grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central minist
25、ries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study,
26、attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of C
27、hina formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary
28、 Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding
29、independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi J
30、inping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed
31、 out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution au
32、thority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, ma
33、inly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members an
34、d the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integr
35、ation of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of
36、 self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disci
37、plinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and pa
38、rty with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all
39、over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to about the content of the negative list moved into s
40、ynchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and
41、 cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipli
42、ne norms, moral declaration issued to all members of the party and the National Peoples solemn commitment. criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the , a total of eight, 281 words, including lead, specification and Party me
43、mber cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as four must eight code. Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as four must
44、 the principle of requirements, strong tone of self-discipline, The higher request for 6 and supervised tenet, the foothold in permanent Bao the partys advanced nature and purity, to reflect the revised standards requirements. Members of self-discipline norms around the party members how to correctl
45、y treat and deal with the public and private, cheap and rot thrifty and extravagance bitter music, put forward the four norms. Party leader cadre clean fingered self-discipline norms for the leadership of the party members and cadres of the vital few, around the clean politics, from civil servant of
46、 the color, the exercise of power, moral integrity, a good family tradition and other aspects of the leadership of the party members and cadres of the four norms norm norm. The Party members self-discipline norms and party members and leading cadre clean fingered self-discipline norms, a total of eight, collectively referred to as the eight. Four must and eight of the content from the party constitution and Partys several generation of leaders, especially Xi Jinping, general secretar