《v电缆沟及配电柜孔洞防火封堵材料.doc》由会员分享，可在线阅读，更多相关《v电缆沟及配电柜孔洞防火封堵材料.doc（60页珍藏版）》请在三一文库上搜索。
1、以下材料使用用途：阻火包 新型防火模块 的作用是设置电缆沟及电缆桥架防火墙使用，电缆沟使用新型防火模块（周围间隙用阻火包或防火堵料填充），电缆桥架使用阻火包。大体积防火墙使用防火模块，小体积防火墙使用阻火包。也可混合使用。防爆胶泥 应用于国防、石油、化工，加油站，变电站，危险性仓库有其它方面的爆炸危险场所，作为线管或电缆配线工程的防爆隔离密封之用。可用来包导钱，接头，电缆，管材，地线等，防止火灾。有机防火堵料 无机防火堵料 适用于工矿企业、高层建筑、造船、冶金、发电、邮电中电线、电缆等贯穿物穿过隔墙时的孔洞封堵，也防止发生火灾时火焰由孔洞向邻室蔓延。有机防火堵料施工方法与防爆胶泥类似。无机防火
2、堵料施工时与浇注混凝土差不多，短时间内即可速固成型，施工时应根据需量调制，以免造成浪费。具体使用用途及施工方法如下：产品类别:阻火包 - 产品名称:阻火包（FHB）产品编号:1013产品简介:阻火包（FHB）产品介绍：FHB型阻火包是我公司根据GA161-1997国家标准研制成功的新型防火配套耐火材料，该产品可根据用户不同的要求垒制成各种形状的防火墙、防火屋，亦可封堵需要制作防火处理的孔洞。遇火时，防火包内的物质受热膨胀，结成蜂窝状整块，有效地将火灾控制在局部范围之内。用阻火包做隔墙，取代了过去用耐火砖、矿渣棉、陶瓷棉等材料，与它们相比，防火包有显著的隔热效果。FHB型阻火包适用于电力、电信、
3、邮政、化工、工矿、企业、建筑当中，电缆、油管、风管、气管、金属管道等贯穿物穿过隔墙或隔层时所形成的空洞的封堵。可阻止火焰蔓延，特别适用于经常更换电缆的重要部位。施工方法：电缆竖井，用阻火网、阻火板或铁板做支垫，将防火包平铺于垫上，垒成隔层，电缆隧道和电缆沟根据国内电缆隧道和电费缆竖井的有关间距规定，在需要设置隔墙处，将防火包垒成防火墙即可。必要时可用角钢做成支架以方便封堵。包装与运输：1、FHB型阻火包用塑料袋外附防火布袋，再用编织袋包装，储存在阴凉干燥处。2、运输时按普通安全固体物质运输，防止雨淋和曝晒。性能指标：外观松散密度耐水性耐油性抗压强度抗跌落性耐火性能包体完整、无破损1.2103k
4、g/m33d内装材料无明显变化包体完整无破损3d内装材料无明显变化包体完整无破损R0.05Mpa5m高处自由落在混凝土水平面上，包体无破损一级防火封堵材料耐火极根180min产品类别:防爆胶泥产品名称:防爆胶泥产品编号:1006产品简介:防爆胶泥产品介绍：是由德国几种高分子聚合物，添加剂，增塑剂等经过特殊工艺配置而成，是一种深黑色，无溶剂（无味），环保，对人体无害的无规则外型的胶泥状物。广泛应用于国防、石油、化工，加油站，变电站，危险性仓库有其它方面的爆炸危险场所，作为线管或电缆配线工程的防爆隔离密封之用。可用来包导钱，接头，电缆，管材，地线等，防止火灾。优点：颜色：深黑发亮，比其它灰白色防爆
5、泥有更好的抗冲击能力，更能吸收爆炸冲击波。性能：有一定的阻燃性和耐油性。粘俯能力强，有防震性，对设备有保护作用。比重：胶的比重大，与其它防爆胶泥相比，在同一工程施工时可以节省更多的材料。品质：无味，无毒，环保，可以让客户更放心的使用。主要技术指标：耐热度90，不流淌，不起泡 耐低温-50，不变化 可塑性5-10mm密封性施加50Kpa的水压，保证一分钟，不滴水，无位移 防爆性配32%混合氩气做传爆试验，结果不传爆 介电强度将样品制成2.5毫米厚的试件耐压，4Kv交流电压，1分钟未击穿 阻燃性用明火烧胶泥，着火极慢 耐油性68号机油浸泡一个月，不流散，不变形 颜色深黑发亮产品类别:新型防火模块
6、- 产品名称:HJ-1新型阻火模块产品编号:1012产品简介:HJ-1新型阻火模块产品特点：宝航HJ-1新型阻火模块，为我国第三代防火封堵产品，为我国国家级防火专家，在吸收世界各地的各种先进防火封堵产品优点的基础上开发的一代全新防火封堵产品，它具有以下特点：1、环保、无污染：整体产品彩多种有机物质组成，溶于自然环境，产品安装时采用自然咬合、无需采用甲醛等含毒胶水；2、遇火不会产生有毒气体：没有飞烟、不脱落。整体产品无卤素成分，遇到火灾不会释放有毒气体，绿色环保；3、可以重复使用：产品采用各模块形式，在遇到封堵位置变更等因素时，只需简单拆卸移动即可。4、耐火时间长：由于产品采用特殊配方材料组成，
7、热量传导性非常差，能够组织燃亮穿透，使耐火时间增长到5小时以上，远过国家规定的3小时标准（为国家一级防火产品）；5、耐水、耐油、耐酸碱性好：产品不溶于水、油等物质，产品稳定性好；6、防小动物、老鼠咬：产品成分加入一种特殊且对环境无污染的物质，从耐有种特殊气味而防止小动物、老鼠咬，克服了原阻火产品需要同时配老鼠药的缺点；7、安装简单、方便：产品为模块化另加特殊的凸块设计，能采取360度自然咬合安装，由于为软性材料，重量轻，采用模型开孔，无需专门技术人员即可完成安装；8、能迅速与周围环境相融合：产品按定尺设计，安装完后平整、有序不会坍塌，外观平整美观；9、产品有效期长：本产品有效期可达15年以上，
8、彻底解决了原阻火产品2-3年必须更换的缺点。一次投入，免维护；免去重复投资和施工，为客户节约大量重复投资资金，经济实惠；10、所有封堵部位经长期使用除人为破坏以外，不会发生自然破损、散落、坍塌等现象；11、突出特点：没有飞烟、不脱落、隔热效果好、散热快、设计科学合理、使用方便、有效期长等。施工模拟图：产品类别:有机防火堵料 - 产品名称:有机防火堵料（XDFD-）产品编号:1015产品简介:有机防火堵料（XDFD）XDFD型有机防火堵料是我公司根据GA161-1997标准研制成功的新型产品，具有耐火极限高、发烟量低等特点。该产品还具有良好的可塑性，耐酸、耐碱、耐腐蚀性，施工、维修比较方便，并能
9、与其他封堵材料（如防火包等）合并用。XDFD型有机防火堵料适用于工矿企业、高层建筑、造船、冶金、发电、邮电中电线、电缆等贯穿物穿过隔墙时的孔洞封堵，也防止发生火灾时火焰由孔洞向邻室蔓延。施工方法：1、将有机防火堵料取出揉成团状，若气温过低，可将堵料连同包装置于40-70摄氏度的温水中加热再进行操作。2、需封堵的孔洞，封堵前需要清扫干净。3、将堵料均匀地铺、嵌、填于孔洞缝隙中，对于较大的孔洞，可先用防火网作骨架，以增加强度。包装与运输：1、XDFD型有机防火堵料用厚质塑料袋外加包装箱包装，适宜储存于阴凉干燥通风处，温度宜在0-45。2、本堵料属不燃、不爆、无毒、无味、无腐蚀性的安全可塑性固体物质
10、，运输中应避免日晒雨淋。性能指标：外观密度耐水性耐油性腐蚀性耐火性能塑性固体，具有一定柔韧性2.0103kg/m33d，无溶胀3d，无溶胀7d一级防火封堵材料耐火极根180min产品类别:无机防火堵料 产品名称:无机防火堵料（XDWD-）产品编号:1004产品简介:无机防火堵料（XDWD-）XDWD-型无机防火堵料是我公司根据GA161-1997标准研制成功的新型产品，该产品由无机材料加化学助剂混合而成，呈粉末状，具有强度高、耐水、耐腐蚀、无气味、施工方便等特点。XDWD-型无机防火堵料适用于电力、冶金、化工、建筑等行业中电缆贯穿孔洞等开口的防火封堵。施工方法需封堵的孔洞，封堵前要清扫干净。将
11、无机防火堵料取出，加适量水，搅拌均匀，施工时与浇注混凝土差不多，短时间内即可速固成型，施工时应根据需量调制，以免造成浪费。包装与运输： 1、XDWD-型无机防火堵料用纸塑复合袋包装，每袋重要为25kg，本产品宜储存于阴凉干燥通风处。2、本堵料属不燃、不爆、无毒、无味、无腐蚀性的物质，运输中应避免日晒雨淋。主要性能指标：外观干密度耐水性耐油性腐蚀性抗压强度初凝时间耐火性能灰色粉末状固体1.710kg/m3 3d,无溶胀3d,无溶胀7d0.8MPaR6.5MPa15mint45min一级防火封堵材料耐火极限180min 河北宝航防火材料有限公司地址：河北省大城县大孟桥经济开发区电话：0316-59
12、58333/5957333传真：0316-5958886手机：15100618555 13473608787网址：http:/（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and d
13、iscipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline,
14、 disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the nec
15、essity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to
16、grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regula
17、tions focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limit
18、ed goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the
19、General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of
20、leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the se
21、cond is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean
22、the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the develop
23、ment of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations i
24、s not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, n
25、eed to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two p
26、arty regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised re
27、gulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 1
28、4 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, p
29、art of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the genera
30、l office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organiza
31、tion of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bure
32、au of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision
33、 of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party
34、characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required
35、 specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 hel
36、d the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regu
37、lations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline sp
38、ecific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the pos
39、itive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusin
40、g on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. T
41、hird, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political r
42、ules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of majo
43、r changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems o
44、f self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the pr
45、ovisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to about the content of the negative list moved into synchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all
46、Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, e