《钢筋砼组合式化粪池说安装施工标准方案.doc》由会员分享，可在线阅读，更多相关《钢筋砼组合式化粪池说安装施工标准方案.doc（55页珍藏版）》请在三一文库上搜索。
1、一、 工程概况本工程位西安市长安区韦郭路与子午大道十字东北角，由1#4#楼、地下车库组成。1#4#楼地上二十六层，地下一层，属框架剪力墙结构，建筑面积72818.01。车库地下一层，属框架结构，建筑面积2520。 本工程最高日用水量为637m3d，最小时用水量为83m3d。采用生活污水与雨水分流制管道系统，并分别排入西侧的市政雨污水管道。厂区共设2座化粪池，化粪池按照过消防车设计。WA化粪池型号为HZ1200，WB化粪池型号为HZ1400。二、 编制依据室外施工图纸；钢筋混凝土组合式化粪池行业标准；根据甲方提供的相关资料；各专业提供的设计图纸。三、施工准备1、复核基坑开挖坐标尺寸，严格按照化粪
2、池生产厂家所提供基坑尺寸开挖基坑。2、复核高程坐标，高差控制在5cm。3、安装前检查基槽内土质情况。4、确认吊装场地，检查坑壁情况，确保做到安全施工。5、由专业工长及安全员对操作班组进行交底。四、施工顺序灰土基础混凝土垫层放线吊装化粪池土方回填防水施工排污井砌筑管道连接检修进砌筑土方回填1、铺设30cm厚3:7灰土，采用机械及人工配合分两次夯实。基础四周外放20cm，压实系数为0.95。2、根据根据信息产业部电子综合勘察研究院2009年提交的智慧城 5期智慧国际岩土工程勘察报告在勘察深度70.00M范围内，场地主要由人工填土、黄土、古土壤、粉质粘土、中砂等构成。地下水稳定水位埋深17.5018
3、.20M，标高416.09417.94m，属潜水类型。非自重湿陷黄土场地，地基湿陷等级按级考虑。本场地无其他不良地质现象。故对其槽低不做特殊处理，垫层采用素混凝土20cm厚，外放20cm。3、根据组合式化粪池相关尺寸及按照说明弹出边线及控制线。并及时组织甲方、监理方及安装班组进行复核，确认无误后妨可吊装。4、使用25t吊车吊装组合式化粪池，吊装顺序为WA为由南向北、由低层向高层吊装。吊装完底层时调整完毕后妨可吊装第二层，共分三层最后吊装井盖。5、吊装完后及时回填周边基坑土方，回填顺序为由西向东回填。应用打夯机配合人工分层夯实，压实系数为0.95。遇到阴雨天要及时苫盖并做好排水设施。6、自然条件
4、为湿陷性黄土层，须做好夯实和砼基础外，更须做好防水施工。以免长时间湿浸造成的不均匀沉降，给工程使用带来隐患。故此将化粪池要求的四级防水，提升为一级防水。达到蓄水池的防水要求标准，才能保证工程质量和长期使用效果。具体方法如下： 1）管层之间采用防水阻隔带。 2）管与管之间接口处采用300mm波纹管连接后，用韩国防水剂做防水砂浆抹实，连接口做完刚性防水后，可达到四级防水效果。但考虑到地震和不均匀沉降等诸多因素会对刚性防水的损坏，故在此基础上再进行两遍柔性防水处理。3）采用高分子SPC120防水材料，将各管缝连接处做成400mm宽防水带。4）高分子柔性防水施工完毕后，为慎重期间，确保万无一失，在薄弱
5、环节的各连接处再进行第二遍柔性防水处理，采用高分子益胶泥达到一级防水功效。本厂生产的钢筋混凝土组合式化粪池，系我国第三代化粪池。优越于砖砌、现场浇注，其卫生环保净化效果好，特别适合施工现场作业面窄的施工，安装后即可回填，不影响下道工序施工，提高工程施工进度。还可以大大降低施工费用，因此建议贵方领导采用本品化粪池，特作出如下施工方案，供贵方参考以便决策。注：以甲方设计部门确定为主，按双方合同规定执行四、安装施工方法：1、本预制钢筋混凝土化粪池设定为 立方米，由 组节组成，达到有效容积。2、组合安装：（示意图附后）3、根据陕西省建筑工程标准要求，遇湿陷性黄土，槽底依土质铺设150-200mm厚C2
6、0砼垫层，（根据槽底土质疏密及沉降情况，确定垫层内是否铺设单层双向12的加强筋），下方铺设300mm厚3:7灰土夯实，当有地下水时，垫层下铺设200mm厚的碎石，基础保证在同一水平面上，基础四周外延200mm宽，压实系数为0.95。4、层高设定：根据设定出水口平面深2.45米基础面。五、安装连接施工方法：每组与组串联，连接采用300mm波纹管进行连接。六、防水施工： 自然条件为湿陷性黄土层，须做好夯实和砼基础外，更须做好防水施工。以免长时间湿浸造成的不均匀沉降，给工程使用带来隐患。故此将化粪池要求的四级防水，提升为一级防水。达到蓄水池的防水要求标准，才能保证工程质量和长期使用效果。具体方法如下
7、： 1、管层之间采用防水阻隔带。 2、管与管之间接口处采用300mm波纹管连接后，用韩国防水剂做防水砂浆抹实，连接口做完刚性防水后，可达到四级防水效果。但考虑到地震和不均匀沉降等诸多因素会对刚性防水的损坏，故在此基础上再进行两遍柔性防水处理。3、采用高分子SPC120防水材料，将各管缝连接处做成400mm宽防水带。4、高分子柔性防水施工完毕后，为慎重期间，确保万无一失，在薄弱环节的各连接处再进行第二遍柔性防水处理，采用高分子益胶泥达到一级防水功效。七、工程保障：经本市共方案施工的化粪池，可达到环保净化效果，优于砖砌和现场浇筑的第一代、第二代化粪池的功效。并保证达到一级防水效果，保证不漏、不渗，
8、即使有一定的不均匀沉降，还可以保证防水功效。八、文明安全施工：保证文明安全施工，施工现场管理有序，配有专业安装施工人员和安检现场负责人，起重吊臂下，严禁站人，避免人身伤亡事故。九、验收标准：经施工安装完毕后，做闭水试验，按省建委验收标准执行。闭水24小时，下降不大于10mm沉降面。 上述施工方案当否，请贵方斧正。 西安港祥水泥制品厂 年 月 日（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions,
9、the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is
10、of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four
11、square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two p
12、arty regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members
13、and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our prede
14、cessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of th
15、e third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revi
16、sed, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicat
17、ed, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, d
18、isciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation an
19、d implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and c
20、riminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is
21、 the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the maj
22、ority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fift
23、h Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The
24、Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part
25、 of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Par
26、ty members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries a
27、nd commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent review
28、ers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Ca
29、n say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committ
30、ee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: fir
31、st, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no sid
32、e round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must
33、 follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party consti
34、tution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and bel
35、iefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. T
36、he revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe mora
37、l and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discip
38、line to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs
39、the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at t
40、he present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low
41、 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to about the content of the negative list moved into synchronization amendment . Three is for
42、all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward high
43、er requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to al
44、l members of the party and the National Peoples solemn commitment. criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the , a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-disciplin
45、e norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as four must eight code. Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as four must the principle of requirements, strong t
46、one of self-discipline, The higher request for 6 and supervised tenet, the foothold in permanent Bao the partys advanced nature and purity, to reflect the revised standards requirements. Members of self-discipline norms around the party members how to correctly treat and deal with the public and private, cheap and rot thrifty and extravagance bitter music, put forward the four norms. Party leader cadre clean fingered self-discipline norms for the leadership of the party members and cadres of the vital few, around the clean politics, from civil servant of the color, the exercise of power, mor