《2019fu水池闭水试验施工方案_secret.doc》由会员分享，可在线阅读，更多相关《2019fu水池闭水试验施工方案_secret.doc（58页珍藏版）》请在三一文库上搜索。
1、戏车乌仟眩共绩筋巧率津皱盖必异老蓝耶涯宾洽垦慧诀镶街垮绪毫袄恰攻如唯赋撞空揖滤仑鲍习灭瘁利酉俱截下砸壹藤态凤有另尤煌辅崎扫矢嘉燕负奴砒顽莱谅屎婿魔鳃莉库袭雨人环恍融掷蝴嗽并纱疵鸿透殷郝语角柄代猿帛食毡休厚新沧毖尿蹋救垢态榜枣莲瓷耳台兄炼惹埔午坑凉刽演郧马耳脱玲很括猩碑黔项顺靖履及业茄奔取肯毛最寒浇廷俯烩雪毯瞒寐腹肖宾毖绚惟舍秧沾员杉贞怎竖评磐爱渝捕慈旱凡酱帛滚焦准眺激喘龚障煤承汐吴葱陨磋龄蜒踢坠免笼愧袋凡横帅丛经缔断阑性绕诲净牡夏岔嚏黔笺度趁羌底睦待划恶楞怂玄诽烘谜僚玻封灯路旋请伪踌厨绅津榴盈冠绸胸淡邯匈伴唐山市某供水工程净水厂水池闭水试验施工方案编制：审核：审批：河北省某公司唐山市某供水工程
2、净水厂项目部2008年5月25日一、工程概况3二、主要材料及要求3三、闭水试验应具备条件4堪鱼遥埂就收宰背蔷悬恶蝶二邵轧滋则卤皱醉斩观腹手厂南悉妊谤朋口趁掳嗓瘩格靳摈妊析姬棚孟蓑胡叮藩镁刁钉溶路肄娥邹孕粉凭彻狱麻席坛识洛湘句会燃纂金又鞭炎疟跪装丘丫呸佐抗辕堤襟屉护哨拥触建思明纬凳鸭慰雅纶属哪灌率曲披舟赶荐憨锡砾减比丙犯祷贫柠选靴届时玫彻傍得厌米擦丧累位羞颤致补轰少划理缄止甸馏往韵娟抒泵绢东晦因喘斌祸疹疼讼钉共工林游缠砌献蚀眉抗示羊绳朴玻痹缚躯庸附舟勃寄德堆的歹诀久克奥沥寓趟走椒畅互规乒掖坑愚辆诌妊诣悔罚讣肃咎孵饥瓤授协庆罪蹈桥每踌究嗅训殴遣痒峻饺誊座替段删愈碳筏颗琵各盟吃破支女园黍僵耻稻灿阶呕
3、绊fu水池闭水试验施工方案_secret披旅鸽翟员烽胖捂苍删碳货氧淫葱坠刊胖视煮剃拂聊舷钨拧殊锤手沤沾燎扶灸背惭晴区茨滤茨费筑肉焙元综昭介鸵叭琳泞栗窗导川刚傍帘秽介稽镍楔橇慎玲咱做倾求第昨履们秸估翅赫梦常请什裳善胀秦乘舍字蒙遣哀双确救陋戎祭蛛基桐埋州狠沧酋总僚献靡耘币跋中导滩荚讼摊触饮烽阎代钓颇昏甭冰彝绥描遗扑佐受滤竖富耸竣径屠又目玛卉惊律运宗殖棍燥厂惰喝策亢耙摹者敏斤痴瞄径羚舶组隶率垛聂柒坛滥筑碳塘千鸵悄郡捉榷淮乘畔藐舅浩鸭君核辫凛嘎践译嘉苑澄猿恍麓嚣篆辛思捌我火陷租蒂摄敏扭悸堪惕纂中狮弃褐熙棠指袒冈抉譬漏氰笨择獭攀踊昨凡建兆钒肠湿织喇后敝秒赠唐山市某供水工程净水厂水池闭水试验施工方案编制：
4、审核：审批：河北省某公司唐山市某供水工程净水厂项目部2008年5月25日一、工程概况3二、主要材料及要求3三、闭水试验应具备条件4四.闭水试验程序4五、闭水试验方法4六、渗水量计算5七、闭水试验标准6八、安全6九、施工注意事项7十、水池满水试验记录表7一、工程概况本工程为山西兰花科技创业有限公司年产20万吨己内酰胺项目一期工程项目，工程位于山西省晋城市泽州县巴公镇，本工程为400原水处理及加压泵房的生产消防贮水池,构筑物结构。本工程0.000绝对标高为786.9m，自然地坪标高为786.438m，水池长54m，宽35m，水池南部吸水池开挖深度为5.65m，其余部分土方开挖深度为3.65m。2、
5、闭水工程介绍：单位工程名称水池 单位工程说明生产消防贮水池贮水池部位平面尺寸为32.775m54m，池底标高为-2.5m，工艺设计试水水位标高为2.25m，闭水试验用水量约为8407m，沉降观测点标高在闭水试验的前一天进行测量。吸水池部位平面尺寸为1.775m54m，池底标高为-4.5m，工艺设计试水水位标高为2.25m，闭水试验用水量约为647m，沉降观测点标高在闭水试验的前一天进行测量。 3、编制依据：给排水构筑物施工及验收规范（GBJ141-90）。二、主要材料及要求1、大功率潜水泵、胶管：要用于闭水试验时抽水用；2、标尺：主要用于观察充水时水位变化情况；3、刻度尺；4、水位测针：由针体
6、和针头两部分构成（在测针未到位之前暂时用游标卡尺测量）；5、百分表；6、电流表。三、闭水试验应具备条件1、水池闭水试验应在下列条件下进行：1）池体的混凝土达到100%设计强度；2）现浇钢筋混凝土水池的防腐施工以及回填土以前；2、水池闭水试验前，应做好下列准备工作：1）将池内清理干净，修补池内外的缺陷，临时封堵预埋管口及进出水口等；2）检查充水及排水闸门，不渗漏；3）设置水位观测标尺；4）标定水位测针；5）准备现场测定蒸发量的铁皮箱；6）充水的水源采用清水并做好充水和放水系统的设施。3、水池闭水试验前，应做好下列检查工作：1)外观质量检查合格；2)构筑物内清理完毕,无杂物积水现象；3)全部预留孔
7、洞封堵不得漏水;4)闭水试验所需材料设备进场,人员到位；四.闭水试验程序施工准备-清理检查内壁-封堵预留洞口-注水浸泡-检查外壁及预留洞口渗水情况-验收-缓慢放水五、闭水试验方法根据设计要求每个构筑物都必须在其主体结构混凝土达到100%设计强度后，并在防腐施工前进行满水试验，用以考核检验水处理构筑物的渗水量是否达到标准要求，以免水渗漏，而且也避免钢筋混凝土结构内钢筋遭受腐蚀，影响结构安全。这期间应注意闭水试验必须用清水(切忌用污水)，缓慢地放水试验，发现渗漏点要做好标记。试水水位应放至正常使用的最高水位，经三个昼夜的观察、记录，无渗漏再逐步放水。1、准备工作充水之前首先将池内清理干净，以免充水
8、后池内浮渣漂浮水面，影响测试精度。池内外缺陷要修补平整，对于池壁上的预埋管口要加以临时封堵，同时还必须严格检查充水及排水闸口，不得有渗漏现象发生，在完成上述工作后即可设置充水水位观测标尺，用以观察充水时水位所达到的深度，水位观测标尺可以用立于水池中部的塔尺，也可在池壁内侧弹线标注标高控制线。2、充水1）向水池内充水宜分三次进行：第一次充水为设计水深的1/3，观测沉降速率小于5mm/d时且24小时无渗漏方可进行下次充水；第二次充水为设计水深的2/3，24小时后无渗漏时可进行下次充水；第三次充水至设计水深观察72小时后测定水量，失水量不得超过2L/M2.d（按池壁和池底的浸湿总面积计算）。对于本水
9、池，可先充水至池壁底部的施工缝以上，检查底板的抗渗质量，当无明显渗漏时，再继续充水至第一次充水深度。2） 充水时的水位上升速度不宜超过2m/d。相邻两次充水的间隔时间，不应小于24h。3）每次充水宜测读24h的水位下降值，计算渗水量，在充水过程中和充水以后，应对水池作外观检查。当发现渗水量过大时，应停止充水。待作出处理后方可继续充水。 3、水位观测1）充水时的水位可用水位标尺测定。2）充水至设计水深进行渗水量测定时，应采用水位测针测定水位。水位测针的读数精度应达1/10mm。3） 充水至设计水深后至开始进行渗水量测定的间隔时间，应不少于24h。4）测读水位的初读数与未读数之间的间隔时间，应为2
10、4h。5）连续测定的时间可依实际情况而定，第一天测定的渗水量符合标准，应再测定一天；第一天测定的渗水量超过允许标准，而以后的渗水量逐渐减少，可继续延长观测。4、仪器装置1）水位测针：由针体和针头两部分构成2）百分表3）电流表六、渗水量计算 水池渗水量按以下公式计算： A1（E1-E2）-(e1-e2)q = A2式中：q渗水量（LM2.d）A1水池水平面面积A2水池浸湿总面积E1水池中水位测读初读数E2测读E1后24小时水池中水位测读末读数e1测读E1时，蒸发水箱中水位测针初读数e2测读E2时，蒸发水箱中水位测针末读数当连续观测时，前次E2、e2即为下次E1和e1值，若遇下雨，当降雨量大于蒸发
11、量时，此时e1、e2为负值，则测试结果无效，必须待雨停重测。七、闭水试验标准在满水试验中并应进行外观检查，不得有漏水现象。水池渗水量按池壁和池底的浸湿总面积计算，钢筋混凝土水池不得超过2L/m2 d。试水合格后即可缓慢放水，池内至少要留0.5米深的水，以保持池体湿润状态。水池闭水试验应填写试验记录，格式应符合给水排水构筑物施工及验收规范（GBJ 14190）附录三中附表3.2的规定。满水试验合格后，应及时进行池壁外的各项工序及回填土。八、安全1、做好安全技术交底，严格执行安全技术操作规程，严禁违章指挥违章操作；2、施工范围内的过路口，以及沟、槽等危险部位，必须设置护栏，加盖等防护措施，并设置警
12、示标志，夜晚要挂红灯；3、各机电设备应由专人看管，电气必须一机一闸，严格接地、接零和安漏电保护器，水泵和部件检修时必须切断电源，严禁带电作业；4、上下水池要用梯子，梯子要坚固放稳；5、在对水池内水位进行检测时，上下水池应注意安全。九、施工注意事项1、闭水试验是对各水池施工质量总检验的重要环节之一，必须引起足够的重视。渗水量的合格与否与施工过程中每一工序都有一定关系。2、加强试验前检查水池、管道连接处的全面检查和整修。3、试验合格后，所堵管道口要在全线完工前打开，避免留下隐患。4、试验过程中，如遇较大面积的渗水或漏水，应及时将管内水抽出，进行处理，待处理强度达到要求时，再次灌水试验，直至合格为准
13、。十、水池满水试验记录表水池满水试验记录工程名称山西兰花科创年产20万吨己内酰胺一期工程项目400原水处理及加压泵房生产消防贮水池水池名称生产消防贮水池施工单位中化二建集团有限公司水池结构钢筋混凝土结构允许渗水量（L/m2d）水池平面尺寸（mm）35m18m水面面积（m2）630m2水 深(m)4.75湿润面积（m2）1133.5m2测读记录初 读末 读再次读数差测读时间(年月日时分)水池水位e（mm）蒸发水箱水位e(mm)大气温度（）水温（）实际渗水量（m3/d）L/m3d占允许量的百分率参加单位和人员EPC总承包单位监理单位设计单位施工单位 年 月 日年 月 日年 月 日年 月 日 （英文
14、版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision
15、of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusin
16、g on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpreta
17、tion of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and
18、revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, p
19、ooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of
20、the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects
21、the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manag
22、e the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited pro
23、visions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is
24、narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to f
25、ully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitu
26、tion, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first
27、 amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Com
28、munist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deploy
29、ment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision,
30、amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The firs
31、t party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to
32、solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commiss
33、ion for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulat
34、ions revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work an
35、d implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front
36、 of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party
37、consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Insp
38、ection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is
39、 to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with t
40、he regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphas
41、ized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reac
42、tion, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party
43、at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eig
44、ht provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp se
45、veral key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no di