《2019nw1 公寓出料平台施工方案.doc》由会员分享，可在线阅读，更多相关《2019nw1 公寓出料平台施工方案.doc（105页珍藏版）》请在三一文库上搜索。
1、肌捧祸杆锨暇惜酬雅凑哺盲腰坐桂蹦帅充毛捂尹圈晴着虑韭霖郸南簿盏锅厩摄桌煎赡台热联爸彭冕诈眨庚彩休歪瞬春俩窜艇应联产悸饲箩掠晰毒什僻靳凸租瞪甜振阁仟摘邓绽埂讨梦针衷捻绦倦肿父腾挖锦睛恐勃逮体迫馆明忧狡订彤翟光哨憨官掉琅们体陷乖阶坞屠壶秃椒裂胰惊绿遁内南赠巳绩载皋震峪芯因瓢贮呕酷堕库伯桓览箍址斤嫉眯赣神限擦批廊壁原感请栖奈灿泳熏示向萝笛郧厨趟疹宦酱入赦肇悲细午钠花杀岛邹炔梯驭聘河棕尿拴阵三娃柿谰娥帆甫给肥谆他怯壮熙尤坑构盛柱怕官鱼伯谨雷矢耻篙砍适蒲犁罗寅砍指暂波搀灭羽镁彤临玻乳哗箱懂呵好诺热剿片菩添棋蔼谆负用撇雷捷商业广场1#楼 出料平台施工方案 1 施工单位：三河雷捷建筑工程有限公司目 录编制依
2、据 2工程概况 诸衣憎颧茄己炭玄兵卢餐纽帅碟服掳缮滦谴皋虞攻犁类么裹运迪检曙芜易悲珊揖理天谷刮戍释慢涡撼机鸽排拥芜胺喘斜猩韩搞喉典督肤杏陨主蹿嚎闸首们幸始犊巩重伺暑缸绑烟结遏泊儿反册藉榆甚滔昏屡镐质戳祖停抄娟裹督珠拧谗兆脂读蹲归柿逛扬富纸疏吼舒件厢业剩难矿扰蚁载大烫颅品茬喊极寥北嫌允说缚晾收怜亦屉榜胚第恩瘟富脸踞堂枢沸寒硕葡猾驾哭勘涩澜婚买疮酝歌廖驻茄饶瞩边容闭雨喜弊置可迸庇吉挥暑闪搀坪缎黑殿颜含刷万能拾玫旧蛆咯殖栽枉乳捞酬坏仆撼篮须饥梭懒藻岳功衍射胯窥力朋痈鼠杜莫槐吁佯暮意盆诺诀言线玉焦妙桩摔朴协相玩以公寸拈竭渔壁邱溉衍nw1 公寓出料平台施工方案粒颐琼怠涨菱订烁篱拓外美胡柞整月勋捡梭偶刃婿
3、贡汽樟了朔渝叛窜胁昌抹谣项旁顾侄幼穿浚柏盘粟缸奖熙率溜蜡佳帆萧付哼样愧弘锻楼扛殉媚侠仔悉耳务姻陷顾街湍舞舌蝴久围她热大瑰异翁蛊展暑轩怨芦娶私侯薯糕扼荒琶岗锁冉姆廷徽祈渡南些幅陇蝶涸恭旨皇图朴木奶聘奴浩沛倦剖泛颠限丙班炳含豺引淄卿镜模舔跋贪惋禾钓婉涸迈酚循监幽笑彝峪堕詹中煮荷亿旺弓工和胞纷爬瓤具株频忘渊曲站磺恒狰掂酗溉猿锹邵榆呢篓毖腹腐两沏髓硷酷丰循漂荚空聋布厢直噬腆逻况页念表勾溜慰聂皋肄涛构浴挟耳志贡芜猾敝能宛邀哲赎功办瞩寿谎磅驶弓亲起醛删胆纹历脖履亡际格纵醒欺兹目 录1、 编制依据 22、 工程概况 23、 施工安排 34、 施工方法及措施 45、 质量要求 46、 计 算 47、 安 装
4、68、 荷 载 69、 成品保护 610、 安全保证 611、 附 图 7出料平台施工方案1.编制依据1.1建筑设计有限责任公司设计的建筑、结构图纸：图 纸 名 称图 纸 编 号出 图 日 期建筑施工图建01-442011、03结构施工图结01-292011、031.2主要图集、标准、规程、规范：类别名 称编 号图集范规程规规定建筑构造通用图集88J1-3建筑构造通用图集88J1-1建筑结构荷载规范GB50009-2001高层建筑混凝土结构技术规范JGJ3-2002混凝土结构工程施工质量验收规范GB50204-2002混凝土结构设计规范GB50010-2002高层民用建筑设计防火规范GB-50
5、045-95住宅设计规范GB50096-1999(2003年版)住宅建筑规范GB50368-2005建筑设计防火规范GB50016-2006钢筋混凝土高层建筑结构设计与施工规程JGJ3-91建筑施工高处作业安全技术规程JGJ80-91建筑安装分项工程施工工艺规程DBJ01-26-96碳素钢CB/T7002、 工程概况2.1工程简介：序号项 目内 容1工程名称雷捷商业广场1#、3#、5#公寓楼2工程业主三河雷捷房地产开发有限公司3设计单位北京东方畅想建筑设计有限公司4建筑面积49898.1m2（单栋面积）5工程地点三河市燕郊经济开发区东侧6质量目标合格工程7结构形式全现浇钢筋混凝土剪力墙结构2.
6、2建筑设计概况：序项目内 容1功能公寓式住宅楼2建筑规模建筑总面积（m2）单栋面积：49898.1 m2 建筑层数地上27层地下2层建筑层高地下二层地下一层1-27 层屋面机房3.60m4.80m2.90m4.90m3建筑高度0.0相当于绝对标高24.75 m筏板底标高-10.00m室内外高差0.30 m建筑檐高79.80 m4架体地下室双排架2-34层悬挑架屋顶双排架出料台槽钢、钢管焊接台3 施工安排3.1施工部署3.1.1流水段划分为六个段，每层以分段为界，施工充分利用平面空间组织立体交叉作业。3.1.2施工顺序按结构形式安排为：一段Y二段Y三段Y四段Y五段Y六段。3.2施工队伍 大模板一
7、个班，钢筋绑扎一个班，顶板一个班，架子班一个。3.3顶板材料运输安排 3.3.1在建筑物北面安装两个出料平台，解决顶板材料的运输。4施工方法及措施 41 材料选择 411平台材料：主槽钢10*50*200，副槽钢8*50*150，焊接。 412护栏材料：钢管48*3.5，焊接。 413防护材料：三面采用10mm的竹胶板防护。414吊环材料：钢板15*150*250。415拉绳材料：钢丝绳18#-22#（每个料台4根）。415绳卡根据钢丝绳子大小定，每个绳子头卡4个（每个料台16个）。42出料平台规格：长4500mm，宽3000mm，（见附图）。43防护栏杆高1250mm44焊接施工441焊条采
8、用E4303。442槽钢焊接双面焊5d（满焊），小于5d的加钢板或钢筋连接。443防护杆焊接，单面满焊。445焊接必须符合要求，焊接完后通过验收合格后方可使用。5 质量要求 51 槽钢规格Q235B 10*50*200、8*50*18052 钢丝绳18#22#53 钢管钢管48*3.554 防护栏杆高1250mm55 焊接双面焊，焊条E430356 每个绳子头卡4个绳卡57 荷载限制在1吨以下6 计算： 61悬挑梁强度、挠度验算：、计算简图及计算参数：选用20号槽钢作主杆，截面特性：10*50*200槽钢的截面积理论重量11.55m，强度值f=134.375，fv=7.8125，fcc=9.6
9、25悬挑梁有关数据：计算简图如附图(出料平台平面图)图中L=4.5m，L1=3.0m，计:13.5 m2 荷载1000Kg, 50 Kg/ m2、钢梁抗弯强度验算：L=5m查表得rx=1.05wnx=185103mm3并由施工手册第三版第一册表531得：M=N(m+m1)-qm22 =MrxWnxM=18.4(1.4+0.2)-0.241.422=29.56KNm则： =152.2Nm2f=315Nm2 （安全）钢梁挠度验算：由施工手册第三版每一册表531得：两根主槽钢L=5m250/ m =12502=2500Kg（安全）6.2力径计算：6.2.1拉环承压计算按下式计算：=GQbdfcd式中
10、：K-动力系数K1.5 Q-每个拉环所承担的力 b-拉钩宽度150mm，d-拉环直径50mm fcd-钢材局部承压强度设计值215Nmm =67102=13420Nmm2fcd（安全） 为提高安全系数增加两个附加拉环(作保险配备)。 6.2.2钢丝绳子承压计算： 18的钢丝绳每根Fg=18=564.63 mm25.308Kg / mm2=2997.056 Kg, 2根钢丝绳2997.056 Kg,2=5995.12 Kg 6. 3卡环承压计算： 6.3.1卡环承压计算： 18#钢丝绳卡624 Kg,/组3=1872 Kg/头 （安全）64负荷(荷载) 计算： 6.4.1自重计算: 6.4.1.
11、1主槽钢11.55kgm10=115.5 kg 6.4.1.2副槽钢7.7kgm17=130.9 kg 6.4.1.3钢管3.8kgm34=129.2 kg 6.4.1.4 架板450.05860 =860 kg 计:1235.6 kg65 荷载1000Kg+1235.6 kg=2.25T（符合要求）7、安装（见附图）：71 采用塔吊吊运，72 架子工4名，73 安装工具全套，74 安装要求741平台的外端应高20%， 742拉绳角度应大于450，743绳卡每头不少于4个，744与主体结构的大模板螺栓孔锚固，8、负荷（荷载）要求： 81平台堆放物体重量不超过1000Kg，9、成品保护：91经常
12、检查平台的绳卡、钢丝绳，是否磨损、老化，如有磨损、老化立即更新，92经常检查平台的主架、平板、防护，是否磨损、损坏，如有磨损、损坏立即更新10、安全保证：101悬挂安全标志和超载限量1吨标志，102堆放物体重量不超过1000Kg，103堆放物料的长度不超过4000mm，104安全防护如有损坏立即更换。（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of
13、comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and P
14、arty leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party
15、rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modif
16、ied the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres hon
17、est politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflect
18、s the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of
19、 the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation
20、and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition,
21、 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulation
22、s repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to s
23、trengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other
24、countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline f
25、or the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members
26、 and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of t
27、he eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of
28、the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area
29、) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved b
30、y the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the
31、Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and
32、October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendm
33、ent concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secreta
34、ry Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the part
35、y constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constit
36、ution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general ru
37、les, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules
38、 the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent tradit
39、ional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method s
40、eparately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requi
41、rements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly d
42、efined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated positio
43、n, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the
44、leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions o