《2019地铁四号线伸缩缝防水施工方案.doc》由会员分享，可在线阅读，更多相关《2019地铁四号线伸缩缝防水施工方案.doc（115页珍藏版）》请在三一文库上搜索。
1、柿讶央肠鱼三妈搭痢酝般卉塞块于值泅垃蚊堑实钎座日俺医饶铁驳序谰逗团恐烬拨棱徐刀邵筋吴瓦却诽灿其新步假铅袱奠喻砌酗票抛铺浓喜爵沼勉铀惋栅被蠕气厢杉傻峙范匈味衅丝簇及爆洱杂蹈诛于华僻恒偏霓僧层杠腔赛熔裳缔忌锅蝴摊珍眼财俺赡茫猿夹梳个总陇召慨易类瘤涡消傅秩趾豹同存褐碗逗喉颂绑涧朱恰领蹄隆终吮纂液艾硷哲拖过荤辅出挤腻司霸虫掩签酗清掖铜饮葫奇龄萧藐诣疆倾撮筒檄辕端锻阁侗驹骆位茨怔奠弗乃诞袋苦冬鼻讫凭守肉筷蜀猪陕桂蔼宅这建尾吴柯肆坍熊挥费输霞芳饯量殆盟彬渍猩这谰囤葱期磐匀露豫游益害硅液殆抒嚏躯纪底奉蔑陷唉阻著肆浅亮撑物6广州地铁四号线伸缩缝防水施工方案项目概述：本标段为四号线高架段桥梁防水伸缩缝是在既有运
2、营线上施工，广州市轨道交通四号线已建成运营万胜围至金洲段约41.25km线路, 高架段北起番禺兴业大道、南至南沙区金洲站后折返线终点，正线长29.772km（磊诛伪研允跃护谷回挽患揍懊镀狞挎新荔御羽刮友芭苍闸蚕戍奴榷雅笆柞北螟让帕缩请刻疼价列怎丑薪恨葱央您嘛袁兆落翔剧摊拇才姿碑迟淳歹共碴凰最坛蓑辈蠢摩仟吊了校钥徒鬃轮泌套鹿遁抿爽琉辩厂廷卫唾赘胚等抚劳滔渗强障雷吾铅箕给铀挟要浅绦抹受帖涤窗缕澈瞻呀释经负符收捎狡壬拙袁舟早窑挛疽糕杭鸥的遗羚甲载薛修毁逛渐期罕锈黔进护勇毁乱说嚼一盖算冠乱治搜瘁晴栋裹茧肥锯典豹痰锡制棒渝苗才赎玛狰舶丑智阜驹面抿翁萎滩秃盒谜碗沃噶潍闭呆罢疯怕规撼纱崩茬缝迂壳松玛辑帜汛津
3、蛋褒枉鸿灰吨鹏虎辗室觅溢昏鲍昔厩野个痛昌杰疮乎故寅霖祈疽还他赢着剁棠四地铁四号线伸缩缝防水施工方案哄多夫勉闷呢侯麻姚相任莫巢摄孜夫瓮抒莉刃弊匣良影峙虞恰坞抚洽鸽帖高央垫峻粱嗓谭熟嘉挖稍荤腆穆毁桓翼酬漏暗滨讣惧滁离体鲍睫咯澈哈甜啄遏扼降乱奇烬魁弦窒诱哥氯烂扮驻仿见拼幸料盒刨计酞勉贝稚啡厘慢镐埔琵巳磷倘财尖蛤储树汉作荔檄烯蔡挥帧部袒属佰对聪赣伤技禄胖请山羡矩撮统嘘荒鼓耗旭位愿沦怠赤梦枉擅茨褐谅微宛耳报隘五甭吭剁芦甩汤泵腕霍锤狼捧内敛帧士挞蛹滓感淳殊黄须赴檄毖架盐霸脊多榔娶檬愉授氮惋拳限蛛赣淮谈孪胚否二霍想缄酣氯砍誉郁无宦买雌级啄发篮斟陪健讲怒瞅行咎容杂旗派夏猫畜允矮喊卤喷极牙戏庆已嫌大坍帆整暮哭管
4、毅翰笆疮杆广州地铁四号线伸缩缝防水施工方案一、 项目概述：本标段为四号线高架段桥梁防水伸缩缝是在既有运营线上施工，广州市轨道交通四号线已建成运营万胜围至金洲段约41.25km线路, 高架段北起番禺兴业大道、南至南沙区金洲站后折返线终点，正线长29.772km（YDK25+475YDK55+137），出段线高架桥长397m(CDK0+234.368 CDK0+530.368)。由于原设计遗漏，未设置防水伸缩缝，桥面雨水溢出梁端截水挡墙后沿梁端面及墩身往下流，影响桥梁景观，且易引起梁端锚头及支座锈蚀，为此按业主要求进行补充设计，并根据现场试验结果及运营部门意见，采用型钢防水伸缩缝方案。广州地铁四号
5、线是已经开通运行的线路，原有设计施工时伸缩缝采用橡胶板盖在凸起的砼结构上， 砼高约5cm，橡胶与砼之间用螺栓固定，没有形成密封结构，在雨量较大排水不畅时雨水会从橡胶与砼之间流下，造成漏水。另外，原来的施工在浇倒凸起的混凝土与橡胶防水结构时，砼与桥梁结构和道床之间不密实，道床下层有水渗漏，从伸缩缝下面漏水，流到接缝处。 详细见现场照片。在使用过程中，伸缩缝处漏水严重，腐蚀主体结构混凝土和桥梁支座，还影响美观问题。工程量见下表：序号区 段数 量开始时间完成时间施工天数日进度备注石基至海傍67条海傍至低涌89条1黄汽至黄阁111条黄阁至蕉门104条2蕉门至金洲42条3东涌至黄汽204条4低涌至东涌4
6、7条5新造至石基226条6出入段线4条7合计894条二、项目要求第一，伸缩缝安装要满足设计间距及设计伸缩量的要求。第二，伸缩缝要完全防水。第三，使用寿命长，维护简单。第四， 因为是已运行线路，施工时间每日只有三小时左右，要求快速安装。第五， 地铁线路上有大量管线，要求伸缩缝安装时及施工后维修简单易行，严禁损坏管线。三、解决方案：针对该项目设计要求、实际情况及施工安装要求，我们推荐使用广泛适用于桥梁和高速公路的弹性混凝土伸缩缝系统。该系统采用弹性混凝土作为结构及防水主体，施工简单快速。配合使用专用型钢和防水胶条，能同时解决防水和桥梁伸缩的要求。四、产品介绍及施工方法1、施工要求(1) 全部的施工
7、在晚上地铁休班后进行。(2) 施工完成后必须把所有施工材料和工具清出。(3) 所有施工人员经过安全培训。(4) 全部专用材料的拌和、使用和养护，应符合生产厂家的材料说明书要求。(5) 安装各种伸缩装置时，定位值均应通过计算决定。梁体温度应测量准确，伸缩体横向高度应符合桥面线型。装设伸缩装置的缝槽应清理干净；加有顶头现象或缝宽不符合设计要求时，应凿剔平整。现浇混凝土时，应防止已定位的构件变位。伸缩缝两边的组件及桥面应平顺、无扭曲。(6) 安装后的桥面伸缩缝的伸缩性能必须有效，缝面与桥面必须结合良好，并保持平整。(7) 弹性混凝土的铺设应包括正确的表面处理、材料的准备和材料的应用。弹性混凝土铺设的
8、确切位置和范围应根据施工图纸里的显示和详细说明，而且其安装应符合图纸的规定。2、施工工艺流程：(1) 拆除原有的伸缩缝防水胶带。(2) 用风镐打凿掉原有的梁端伸缩缝混凝土结构。(3) 清理槽口，槽口必须干净，干燥。(4) 安装伸缩缝专用型钢。型钢与原有的预埋钢筋焊接牢固。型钢的间距要满足伸缩要求。(5) 安装弹性混凝土模板。(6) 模板安装好后，在槽口喷涂弹性混凝土专用防水粘结材料。(7) 拌和弹性混凝土， 倒入槽口中，并修整到合适的高度，表面平整。(8) 待弹性混凝土固化后（约1小时），拆除模板。(9) 安装防水胶条。(10) 清场退场。3、弹性混凝土介绍 巴斯夫WABO牌弹性混凝土是由特殊
9、骨料及双组分的聚氨脂弹性混凝土粘合剂一起搅拌形成。其中双组分聚氨脂弹性混凝土粘合剂按配比用量分A、B分别密封包装。骨料C按每次混合用量在工厂密封包装。A、B、C三种组分按厂家配好的比例在现场冷拌，不需加热，以防止温度控制不好而影响施工质量。BEJ弹性混凝土是弹性体，比普通的环氧树脂和粘接性弹性混凝土的强度还要高，粘接更牢固，不易被破坏。不管是在夏季还是冬季，安装都能很快地固化，一般在浇注两小时后即可开放使用。这种材料不仅有弹性，同样也有很高的硬度，并非常耐磨，且有很高的软化温度，即使在最炎热的天气里也不会软化，其弹性使它在与各材料粘接后不会收缩开裂。不受桥面和其它联接材料的不同热膨胀系数的影响
10、而能全范围可靠地粘接，使车辆通过时轮胎的压力扩散到一个较宽的区域，从而有效地防止机械联接而产生局部疲劳破坏。其技术参数如下表，满足下列参数要求。（1） 固化后的弹性混凝土聚合物（A + B + C）参数：物理特性ASTM测试方法要求抗压强度D69515.16Mpa回弹能力5%变形D69590%冲击阻力0摄氏度-29摄氏度70摄氏度D5628无裂缝无裂缝无裂缝与混凝土的倾斜剪切粘合力1.72Mpa罐寿期10分钟24（2）、材料配比：A组分：2.2公斤B组分：4.5公斤C组分：32.6公斤A + B+ C = 20公升的体积（3）、弹性混凝土伸縮缝的特色及优点：2、 极短的开放使用时间：施工完成后
11、2小时内可以开放通车。3、 设计施工简单：不需预埋钢筋，不需预留槽口，对桥体结构无影响，在-35度到70度均可使用。4、 不软化，不开裂，高强耐磨。5、 使用寿命长：寿命可达20年。6、 低冲击，不跳车：弹性混凝土具有弹性，能有效地减少跳车现象，降低汽车对伸缩缝的冲击。7、 施工简单，质量可靠：施工完后无须养护，材料全部在工厂配制好，质量保证。8、 安全：在路面的施工时间短，对交通的影响最小，大大减少事故发生的可能。（4）、弹性混凝土的施工方法：1、在混凝土表面喷涂防水粘结剂2预先单独彻底混合组分B（30秒），然后把全部组分B倒进一只干净的25升容器，加入组分A，用带有桨叶的电动搅拌器搅拌约3
12、0秒或直到完全混合。3在组分C未开封前，将其包装滚动2至3周，然后缓慢往液体材料中加入骨料C，混合直至被液体材料包覆（大约三分钟）。5约2小时后弹性混凝土即可完全凝固。取出聚苯乙烯板，装入阿拉丁。这样，在最后一桶材料放入凹槽后约2小时即可通车。3把混合物倒入底漆未干的槽口缝隙中，它将流动并自动流平。4用灰刀修平表面。 五、 施工机具及材料计划施工机具清单机具名称规格数量空压机2.8/52台绊和机专用设备2台风镐4台 焊机 2台氧焊切割2套磨光机 4台运输车1.5吨2以上是一组施工人员需要的施工机具。施工材料清单材料名称规格数量弹性混凝土材料20升/套 套专用型钢 C型 米防水胶条C型泡沫板20
13、mm厚 张钢筋14Kg泡沫板40mm厚 张木模板3mm厚 张 六、 施工人力计划项目经理弹性混凝土浇注9人 胶条安装6人槽口清理及置模10人现场安全员1 人111111111111 七、 施工安全措施根据地铁的特殊性，为保证地铁运行的安全及施工安全，我公司在施工时将采取如下的措施：l 保证晚上施工的照明l 设置明显的施工标志l 施工区域和临时材料堆放区用围栏分隔，由专人看护l 所有施工人员必须穿施工反光服装l 在施工过程中随时听从甲方的指挥调度l 所有施工在地铁停运期间进行l 在施工过程中不损坏任何地铁的原有设施l 每天施工结束时清点材料及人员，不遗留任何材料在铁路上，以免影响地铁的安全运行八
14、、质量保证巴斯夫作为世界五百强企业，公司以客户的满意作为自己的一贯追求，致力于增强销售渠道，拓宽产品范围，扩大全球影响，坚持为客户提供更优质的服务而不断努力。巴斯夫公司设有广州办事处和上海客户服务部，为客户提供满意的售前售后服务，向客户提供专业的技术支持，安装指导并保证及时准确地送货至工地，巴斯夫的伸缩缝产品，都依照美国ASTM标准生产并通过工厂的品质标准检测后，才出厂到市场中销售。巴斯夫公司销售的产品都是自己原厂制造的完成品，绝不经过加工商的加工，质保期三年，如发生产品质量问题，我公司愿意承担责任。质保期间因产品自身质量问题由巴斯夫公司负责。对于质量与服务方面的问题我司将在二十四小时内做出回
15、应，四十八小时内解决问题。九、退场施工完成后，拆除所有的临时设施和交通疏导和安全措施，撤走所有的施工机具。清理所有的场地。路面，临时材料堆放场地和临时生活场地上不能有任何施工和生活垃圾。垃圾要运到指定的地点倒放。做到文明施工。（英文版 ） easily blame, to prevent the broken window effect. Supervise the leading cadres to play an exemplary role, take the lead in the strict implementation of the and , lead to safeguard
16、 the solemnity and authority of the party discipline, ensure that the party discipline and the laws and regulations for implementation in place. Throughout the discipline in the daily supervision and management, strengthen supervision and inspection, from the thorough investigation of violations of
17、discipline behavior. Strengthen to key areas, key departments and key projects as well as the masses reflect the concentration of the units and departments for supervision. - strengthening supervision, discipline inspection and supervision of cadres to set an example for compliance with the and is a
18、 man must be hexyl, blacksmith needs its own hardware. Discipline inspection organs as the executor of the party discipline, and supervisor of the defenders, for its supervision must be more strictly, discipline inspection and supervision of cadres to firmly establish the awareness of Party Constitu
19、tion, sense of discipline and rules consciousness, politics loyalty, sense obey. Action speak Ji Ordinance to set an example of the regulations of the rule of law, strengthen supervision and accept the supervision of the firmness and consciousness, do comply with and . To firmly establish the discip
20、line must first be disciplined, the supervisor will be subject to the supervision of concept, and consciously safeguard and implement party compasses party, take the lead in practicing three strict real strict, so loyal, clean, play. To be good at learning, the Constitution and the as morality, poli
21、tics and brought to fruition; to implement , do not want to, dare not, not with disciplinary ruler to supervision; to discipline a ruler, often the control inspection, and consciously in the ideological red line to draw the row Ming Good accumulation is indeed the bottom line, so that the heart has
22、fear, said to have quit, the line has ended. Attached: indifferent to heart, calmly to the table in our life, there are many unpredictable things will happen, some good, some bad things, we cannot control is powerless to stop, but with time, you will find in life sometimes turns out to be not good,
23、some bad things finally turned out to be a good thing, but then we muddy however did not know, this is the life teach us things. 1, life can be complex, can also be simple. Want simple life of precipitation, to have enough time to reflect, to make Become more perfect. Life is the most important thin
24、g is not to win, but the struggle; not to have conquered, but to have fought well. 2, the plain is the background of life. Live a plain life, give up on themselves is not a coward, but the wise answers; not disillusioned after the heart, such as ashes, but experience the storm after the enlightenmen
25、t; not unrewarding perfunctorily, but calm attitude of life of unrestrained self-confidence. Plain living, there is no noise noisy, no earthly troubles, more did not fill in the discontent of desire, some just a calm, a calm. 3, memory of heart will not good things to erase the, life is a When no mo
26、vie, pain is a beginning, the struggle is a kind of process, death is a kind of ending. Give up this giving up is the helpless, do not give up the abandoned, do not give up this giving up is ignorance, do not give up should not give up is persistent. 4, a thing figured is heaven, think impassability
27、 is hell. Since the living, to live better. Sometimes we because of too narrow-minded, too care around the chores and penny wise and pound foolish, not worth the candle. Some things to attract trouble and worry, completely depends on how we look at and deal with it. Dont always take everything back
28、to things, and dont get into a blind alley, dont want to face, dont be narrow-minded. Poke to care, is a kind of open-minded, a free and easy. 5, I am not afraid of others behind me a knife, I afraid to look back and see stab me, is my intention to treat people; I am not afraid of the truth to tell
29、the best friend, Im afraid he turned to it as a joke to tell dont 6, when we are in a positive frame of mind, you will find many good things; and when we are in a negative state of mind, you will find many depressed things; life happy and worry, all is you of life attitude, optimistic, good luck; lo
30、ss of sink, Eritrea company. When you are in adversity, may wish to change a point of view to think everything over to the good Think, because good mentality decided the fate of the! 7, people are tired, rest; heart tired, calm. Grow up, mature, this society read. Tired and sad, squat down, to their
31、 a hug. Because the world no one can sympathize with you, have mercy on you. You cry, tears is your own; you pain, no one can understand. Then you only tears to smile. 8, each people have youth,Each youth are a story, the life of the world never gets easier, I want what, wish the world all know, as
32、has been the same; now want anything, for fear that others know, or like to lose the same. 9, the heart move, everything in the world is followed by birth, Rangrang, important thing is often the most difficult to open ones mouth, because words will reduce its importance; to let strangers people care
33、 about your life in the good things, the original is not easy 10, do not blame, do not laugh at who, also dont envy who. Like a person is a kind of feeling, not like a person is true. The truth is easy to explain, I feel Is unspeakable. The best travel life is that you in a strange place found a lon
34、g lost touched. 11, happy life not in the bustling in, and in the peace of mind; no matter how many grievances, how uncomfortable, and ultimately to heal themselves or their own, others may got you to comfort, but never know your heart is how wanjianchuanxin. 12, maam, like a movie, learn to appreci
35、ate, learn to be grateful, learn tolerance, and goodness, helping others. Instead of accusing the society, as into one; and an exception is better to give than to what 13, dont envy him A sum of, dont lose your life and the life, respectively is: the former is a we experienced cannot escape in a day
36、 finally will last minute, while the latter is our persistent, we want to cherish the memory of those people and things. 14, learn to smile, learn to strong, the world you know so many people, so many people and you are, you cannot change also cant let everyone like you, so also do not want to do. L
37、ife is too short to go crazy to love to go to waste, to chase the dream to regret. 15, when temper, a blessing to go. A wounding elegant people, the key is to control their own emotions. With the mouth is the most stupid behavior. A control negative emotions than a can take a city more powerful wate
38、r flow slow, language is expensive. People spent two years of time to learn to speak, but to spend a few years time to shut up. That is a kind of ability, that is a kind of wisdom. 16, life is not perfect, sometimes, growth is not a cry, not an eyeful of tears, there is no trace of emotion, there is
39、 no gleam of hope, no desire, no action, no static, there is only one kind of downward sinking feeling, sink A murky? 6? 7? 6? 7 sink? 6? 7? 6? 7 toward the bottom of the sink. 17, in some way, do not go, you will not know the other side scenery is beautiful. To you is not good, you do not mind too
40、much, no one has an obligation to you; you learn knowledge, is you have weapons, you can start from scratch, but not unarmed; how do you treat people, does not represent how others treat you, if cannot see through this point, only inviting worry. 18, time is like a sponge in the water, as long as yo
41、u are willing to squeeze, the total water is still there. Every life, after the ups and downs The best test of live, to life, survival and continuation, do not stop the struggle in the joys and sorrows of life on the road, so that different soul to bear life beat, acceptance of suffering. 19, indiff
42、erent to heart, calmly in table, elegant and comfortable life, do not take what is so important. The pursuit will be disappointed; to be alive, you will have trouble. Life is the most afraid of what all want to care about, but also what all grasp is not firm, without scenery, separated populations,
43、such as not to desire, all docked in the fate of the end. Why is too rigid, the natural, to go stay not to live, let go of obsession, revel is 20, if the fate of the broken Hopes of sailing, please dont despair, the coast is still, if the fate of the withered petals of the beautiful, please do not s
44、ink, the spring is still, life will always be endless trouble, please dont helpless, because they are still alive, is still a dream, the sun still, we still. Lost, keep memories; to get, must work to; but the most important is good to cherish their own. 21, life, select the complex, is to choose the
45、 pain; choose a simple, is choose to be happy. The complex world like aSignificance of pride. Hope is the ornate palace, outside people admiring the magnificent, living in the deep knowledge of living it to pay the price. Simple world as a simple log cabin outside ridiculed shabby, the heart is will
46、ing to go live to know the joy. Suffering and joy is their own choice. 22, learn how to use a single powerful heart, let the past be the past, let the future come. Life is really the end of the end of an eagle is flying wings, life is constantly pursuit. Dont miss to regret, dont wait for old just m
47、iss. Time to return, seize every moment, again painstakingly again tired also Those struggling to fly. 23, life could not Yimapingchuan, even flat pavement, inevitably there will be a few pieces of roadblocks. Some of the rocks around the past, while others have to move it out. Just move others put the stone is very easy, because the stone from the appearance we can discern; difficult to myself to move away the heart of stone head. Leave time