《BS-EN-60335-2-2-2003.pdf》由会员分享，可在线阅读，更多相关《BS-EN-60335-2-2-2003.pdf（32页珍藏版）》请在三一文库上搜索。
1、BRITISH STANDARD BS EN 60335-2-2:2003 Incorporating amendments nos. 1 and 2 and corrigendum no. 1 Household and similar electrical appliances Safety Part 2-2: Particular requirements for vacuum cleaners and water-suction cleaning appliances The European Standard EN 60335-2-2:2003, with the incorpora
2、tion of amendments A1:2004 and A2:2006 has the status of a British Standard ICS 13.120; 97.080 ? -,-,- BS EN 60335-2-2:2003 This British Standard was published under the authority of the Standards Policy and Strategy Committee on 2 July 2003 BSI 2007 ISBN 0 580 42170 8 National foreword This British
3、 Standard was published by BSI. It is the UK implementation of EN 60335-2-2:2003, incorporating amendments A1:2004 and A2:2006. It was derived by CENELEC from IEC 60335-2-2:2002 including amendments 1:2004 and 2:2006. It supersedes BS EN 60335-2-2:1996 which is withdrawn. The start and finish of tex
4、t introduced or altered by amendment is indicated in the text by tags !“. Tags indicating changes to IEC text carry the number of the IEC amendment. For example, text altered by IEC amendment 1 is indicated in the text by !“. The CENELEC common modifications have been implemented at the appropriate
5、places in the text. The start and finish of each common modification is indicated in the text by tags . Where a common modification has been introduced by amendment, the tags carry the number of the amendment. For example, the common modifications introduced by CENELEC amendment A11 are indicated by
6、 . The UK participation in its preparation was entrusted by Technical Committee CPL/61, Safety of household electrical appliances, to Subcommittee CPL/61/01, Safety of electrical appliances Motorised appliance group. A list of organizations represented on CPL/61/01 can be obtained on request to its
7、secretary. This publication does not purport to include all the necessary provisions of a contract. Users are responsible for its correct application. Compliance with a British Standard cannot confer immunity from legal obligations. Amendments issued since publication Amd. No. DateComments 1553225 F
8、ebruary 2005Changes to Introduction, Clause 2, subclauses 19.1 and 19.7 15716 Corrigendum No. 1 May 2006Correction to Annex ZC 1693528 February 2007See national foreword -,-,- EUROPEAN STANDARD EN 60335-2-2 NORME EUROPENNE March 2003 + A1 EUROPISCHE NORM December 2004 CENELEC European Committee for
9、Electrotechnical Standardization Comit Europen de Normalisation Electrotechnique Europisches Komitee fr Elektrotechnische Normung Central Secretariat: rue de Stassart 35, B - 1050 Brussels 2003 CENELEC - All rights of exploitation in any form and by any means reserved worldwide for CENELEC members.
10、ICS 13.120; 97.080 Supersedes EN 60335-2-2:1995 English version Household and similar electrical appliances Safety Part 2-2: Particular requirements for vacuum cleaners and water-suction cleaning appliances Appareils lectrodomestiques et analogues Scurit Partie 2-2: Rgles particulires pour les aspir
11、ateurs et les appareils de nettoyage aspiration deau Sicherheit elektrischer Gerte fr den Hausgebrauch und hnliche Zwecke Teil 2-2: Besondere Anforderungen fr Staubsauger und Wassersauger Up-to-date lists and bibliographical references concerning such national standards may be obtained on applicatio
12、n to the Central Secretariat or to any CENELEC member. This European Standard exists in three official versions (English, French, German). A version in any other language made by translation under the responsibility of a CENELEC member into its own language and notified to the Central Secretariat ha
13、s the same status as the official versions. CENELEC members are the national electrotechnical committees of Austria, Belgium, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portu
14、gal, Slovakia, Slovenia, Spain, Sweden, Switzerland and United Kingdom. + A2 December 2006 This European Standard was approved by CENELEC on 2003-03-01. CENELEC members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European Standard the
15、status of a national standard without any alteration. Ref. No. EN 60335-2-2:2003 E -,-,- EN 60335-2-2:2003 2 Foreword The text of document 61/2110/FDIS, future fifth edition of IEC 60335-2-2, prepared by the IEC Technical Committee 61, was submitted to the IEC-CENELEC parallel vote. As a result of t
16、he Kista meeting of CENELEC TC 61 in May 2002, a draft amendment prAA containing the relevant existing common modifications was submitted to the formal vote. The texts of the FDIS and the prAA were approved by CENELEC as a new edition of EN 60335-2-2 on 2003-03-01. This European Standard replaces EN
17、 60335-2-2:1995 + A1:1998 + A2:2000. The following dates are applicable: -latest date by which the EN has to be implemented at national level by publication of an identical national standard or by endorsement (dop) 2004-03-01 -date on which national standards conflicting with the EN have to be withd
18、rawn (dow) 2006-03-01 This part 2 has to be used in conjunction with EN 60335-1, Household and similar electrical appliances Safety Part 1: General requirements. It was established on the basis of the 2002 edition of that standard. Amendments and revisions of Part 1 have also to be taken into accoun
19、t and the dates when such changes become applicable will be stated in the relevant amendment or revision of Part 1. This part 2 supplements or modifies the corresponding clauses of EN 60335-1, so as to convert it into the European Standard: Safety requirements for electric vacuum cleaners and water-
20、suction cleaning appliances. When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies as far as is reasonable. When this standard states “addition“, “modification“ or “replacement“, the relevant text of Part 1 is to be adapted accordingly. NOTE 1 The following nu
21、mbering system is used: - subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1; - unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including those in a replaced clause or subclause; - additional annex
22、es are lettered AA, BB, etc.; - subclauses, notes and annexes that are additional to those in the IEC standard are prefixed with the letter Z. NOTE 2 The following print types are used: - requirements: in roman type; - test specifications: in italic type; - notes: in small roman type. Words in bold
23、in the text are defined in Clause 3. When a definition concerns an adjective, the adjective and the associated noun are also in bold. There are no special national conditions causing a deviation from this European Standard, other than those listed in Annex ZA to EN 60335-1. There are no national dev
24、iations from this European Standard, other than those listed in Annex ZB to EN 60335-1. -,-,- 3 EN 60335-2-2:2003 Foreword to amendment A1 The text of document 61/2681/FDIS, future amendment 1 to IEC 60335-2-2:2002, prepared by the IEC Technical Committee 61, Safety of household and similar electric
25、al appliances, was submitted to the IEC-CENELEC parallel vote and was approved by CENELEC as amendment A1 to EN 60335-2-2:2003 on 2004-09-01. The following dates are applicable: -latest date by which the amendment has to be implemented at national level by publication of an identical national standa
26、rd or by endorsement (dop) 2005-06-01 -date on which national standards conflicting with the amendment have to be withdrawn (dow) 2007-09-01 This amendment supplements or modifies the corresponding clauses of EN 60335-2-2:2003. There are no special national conditions causing a deviation from this a
27、mendment. There are no national deviations from this amendment. _ Endorsement notice The text of the amendment 1:2004 to the International Standard IEC 60335-2-2:2002 was approved by CENELEC as an amendment to the European Standard without any modification. In Annex ZC, the reference to ISO 3864 is
28、to be deleted. Introduction An investigation by CENELEC TC 61 has shown that all risks from products within the scope of this standard are fully covered by the Low Voltage Directive, 73/23/EEC. For products having mechanical moving parts, a risk assessment in accordance with the Machinery Directive,
29、 98/37/EC, has shown that the risks are mainly of electrical origin and consequently this directive is not applicable. However, the relevant essential safety requirements of the Machinery Directive are covered by this standard together with the principal objectives of the Low Voltage Directive. _ En
30、dorsement notice The text of the International Standard IEC 60335-2-2:2002 was approved by CENELEC as a European Standard with agreed common modifications. -,-,- EN 60335-2-2:2003 4 Foreword to amendment A2 The text of document 61/3056/FDIS, future amendment 2 to IEC 60335-2-2:2002, prepared by the
31、IEC Technical Committee 61, Safety of household and similar electrical appliances, was submitted to the IEC-CENELEC parallel vote and was approved by CENELEC as amendment A2 to EN 60335-2-2:2003 on 2006-10-01 with a common modification maintaining the coherence with Clause 6 of EN 60335-1:2002. The
32、following dates are applicable: latest date by which the amendment has to be implemented at national level by publication of an identical national standard or by endorsement (dop) 2007-07-01 date on which national standards conflicting with the amendment have to be withdrawn (dow) 2009-10-01 This am
33、endment supplements or modifies the corresponding clauses of EN 60335-2-2:2003. There are no special national conditions causing a deviation from this amendment. There are no national deviations from this amendment. _ Endorsement notice The text of amendment 2:2006 to the International Standard IEC
34、60335-2-2:2002 was approved by CENELEC as an amendment to the European Standard with agreed common modifications. -,-,- 5 EN 60335-2-2:2003 CONTENTS INTRODUCTION.7 1 Scope 8 2 Normative references .9 3 Definitions9 4 General requirement.11 5 General conditions for the tests 11 6 Classification11 7 M
35、arking and instructions.11 8 Protection against access to live parts 13 9 Starting of motor-operated appliances.13 10 Power input and current13 11 Heating 13 12 Void .14 13 Leakage current and electric strength at operating temperature.14 14 Transient overvoltages .14 15 Moisture resistance 14 16 Le
36、akage current and electric strength .16 17 Overload protection of transformers and associated circuits 16 18 Endurance16 19 Abnormal operation 16 20 Stability and mechanical hazards17 21 Mechanical strength .17 22 Construction.19 23 Internal wiring.20 24 Components.20 25 Supply connection and extern
37、al flexible cords .20 26 Terminals for external conductors .21 27 Provision for earthing21 28 Screws and connections .21 29 Clearances, creepage distances and solid insulation .21 30 Resistance to heat and fire .21 31 Resistance to rusting21 32 Radiation, toxicity and similar hazards 21 Annexes .25
38、Bibliography .28 -,-,- EN 60335-2-2:2003 6 Figure 101 Apparatus for testing the abrasion resistance of current-carrying hoses .22 Figure 102 Apparatus for testing the resistance to flexing of current-carrying hoses 23 Figure 103 Configuration of the hose for the freezing treatment 24 Figure 104 Flex
39、ing positions for the hose after removal from the freezing cabinet24 -,-,- 7 EN 60335-2-2:2003 INTRODUCTION It has been assumed in the drafting of this International Standard that the execution of its provisions is entrusted to appropriately qualified and experienced persons. This standard recognize
40、s the internationally accepted level of protection against hazards such as electrical, mechanical, thermal, fire and radiation of appliances when operated as in normal use taking into account the manufacturers instructions. It also covers abnormal situations that can be expected in practice and take
41、s into account the way in which electromagnetic phenomena can affect the safe operation of appliances. This standard takes into account the requirements of IEC 60364 as far as possible so that there is compatibility with the wiring rules when the appliance is connected to the supply mains. However,
42、national wiring rules may differ. If an appliance within the scope of this standard also incorporates functions that are covered by another part 2 of IEC 60335, the relevant part 2 is applied to each function separately, as far as is reasonable. If applicable, the influence of one function on the ot
43、her is taken into account. This standard is a product family standard dealing with the safety of appliances and takes precedence over horizontal and generic standards covering the same subject. An appliance that complies with the text of this standard will not necessarily be considered to comply wit
44、h the safety principles of the standard if, when examined and tested, it is found to have other features which impair the level of safety covered by these requirements. An appliance employing materials or having forms of construction differing from those detailed in the requirements of this standard
45、 may be examined and tested according to the intent of the requirements and, if found to be substantially equivalent, may be considered to comply with the standard. -,-,- EN 60335-2-2:2003 8 HOUSEHOLD AND SIMILAR ELECTRICAL APPLIANCES SAFETY Part 2-2: Particular requirements for vacuum cleaners and
46、water-suction cleaning appliances 1 Scope This clause of Part 1 is replaced by the following. This International Standard deals with the safety of electric vacuum cleaners and water- suction cleaning appliances for household and similar purposes, including vacuum cleaners for animal grooming, their
47、rated voltage being not more than 250 V. It also applies to centrally-sited vacuum cleaners #and automatic battery-powered cleaners$. This standard also applies to motorized cleaning heads and current-carrying hoses associated with a particular vacuum cleaner. Appliances not intended for normal hous
48、ehold use, but which nevertheless may be a source of danger to the public, such as appliances intended to be used by laymen in shops and other premises for normal housekeeping purposes, are within the scope of this standard. NOTE 101 Examples of such appliances are appliances intended to be used for normal housekeepi