《ISO-22717-2006.pdf》由会员分享，可在线阅读，更多相关《ISO-22717-2006.pdf（20页珍藏版）》请在三一文库上搜索。
1、 Reference number ISO 22717:2006(E) ISO 2006 INTERNATIONAL STANDARD ISO 22717 First edition 2006-02-01 Cosmetics Microbiology Detection of Pseudomonas aeruginosa Cosmtiques Microbiologie Dtection de Pseudomonas aeruginosa Copyright International Organization for Standardization Provided by IHS under
2、 license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- ISO 22717:2006(E) PDF disclaimer This PDF file may contain embedded typefaces. In accordance with Adobes licensing policy, th
3、is file may be printed or viewed but shall not be edited unless the typefaces which are embedded are licensed to and installed on the computer performing the editing. In downloading this file, parties accept therein the responsibility of not infringing Adobes licensing policy. The ISO Central Secret
4、ariat accepts no liability in this area. Adobe is a trademark of Adobe Systems Incorporated. Details of the software products used to create this PDF file can be found in the General Info relative to the file; the PDF-creation parameters were optimized for printing. Every care has been taken to ensu
5、re that the file is suitable for use by ISO member bodies. In the unlikely event that a problem relating to it is found, please inform the Central Secretariat at the address given below. ISO 2006 All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utiliz
6、ed in any form or by any means, electronic or mechanical, including photocopying and microfilm, without permission in writing from either ISO at the address below or ISOs member body in the country of the requester. ISO copyright office Case postale 56 CH-1211 Geneva 20 Tel. + 41 22 749 01 11 Fax +
7、41 22 749 09 47 E-mail copyrightiso.org Web www.iso.org Published in Switzerland ii ISO 2006 All rights reserved Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo re
8、production or networking permitted without license from IHS -,-,- ISO 22717:2006(E) ISO 2006 All rights reserved iii Contents Page Foreword iv Introduction v 1 Scope . 1 2 Normative references. 1 3 Terms and definitions. 1 4 Principle. 2 5 Diluents and culture media 2 5.1 General. 2 5.2 Diluent for
9、the bacterial suspension (tryptone sodium chloride solution). 3 5.3 Culture media 3 6 Apparatus and glassware 5 7 Strains of micro-organisms. 6 8 Handling of cosmetic products and laboratory samples . 6 9 Procedure 6 9.1 General recommendation 6 9.2 Preparation of the initial suspension in the enric
10、hment broth 6 9.3 Incubation of the inoculated enrichment broth. 7 9.4 Detection and Identification of Pseudomonas aeruginosa 7 10 Expression of results . 8 11 Neutralization of the antimicrobial properties of the product 8 11.1 General. 8 11.2 Preparation of the inoculum 8 11.3 Validation of the de
11、tection method. 8 12 Test report . 9 Annex A (informative) Other enrichment broths. 10 Annex B (informative) Neutralizers of antimicrobial activity of preservatives and rinsing liquids. 12 Bibliography. 13 Copyright International Organization for Standardization Provided by IHS under license with IS
12、O Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- ISO 22717:2006(E) iv ISO 2006 All rights reserved Foreword ISO (the International Organization for Standardization) is a worldwide federation
13、 of national standards bodies (ISO member bodies). The work of preparing International Standards is normally carried out through ISO technical committees. Each member body interested in a subject for which a technical committee has been established has the right to be represented on that committee.
14、International organizations, governmental and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization. International Standards are drafted in accordance wit
15、h the rules given in the ISO/IEC Directives, Part 2. The main task of technical committees is to prepare International Standards. Draft International Standards adopted by the technical committees are circulated to the member bodies for voting. Publication as an International Standard requires approv
16、al by at least 75 % of the member bodies casting a vote. Attention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. ISO shall not be held responsible for identifying any or all such patent rights. ISO 22717 was prepared by Technical Committe
17、e ISO/TC 217, Cosmetics. Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- ISO 22717:2006(E) ISO
18、2006 All rights reserved v Introduction Microbiological examinations of cosmetic products shall be carried out according to an appropriate microbiological risk analysis in order to ensure their quality and safety for consumers. Microbiological risk analysis depends on several parameters such as: pot
19、ential alteration of cosmetic products; pathogenicity of micro-organisms; site of application of the cosmetic product (hair, skin, eyes, mucous membranes, etc.); type of users (adults, children under 3 years). For cosmetics and other topical products, the detection of skin pathogens such as Staphylo
20、coccus aureus, Pseudomonas aeruginosa and Candida albicans may be relevant. The detection of other kinds of micro-organism might be of interest since these micro-organisms (including indicators of faecal contamination e.g. Escherichia coli) suggest hygienic failure during the manufacturing process.
21、Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- Copyright International Organization for Standa
22、rdization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- INTERNATIONAL STANDARD ISO 22717:2006(E) ISO 2006 All rights reserved 1 Cosmetics Microbiology
23、 Detection of Pseudomonas aeruginosa 1 Scope This International Standard gives general guidelines for the detection and identification of the specified micro-organism Pseudomonas aeruginosa in cosmetic products. Micro-organisms considered as specified in this International Standard might differ from
24、 country to country according to national practices or regulations. In order to ensure product quality and safety for consumers, it is advisable to perform an appropriate microbiological risk analysis to determine the types of cosmetic product to which this International Standard is applicable. Prod
25、ucts considered to present a low microbiological risk include those with low water activity, hydro-alcoholic products, extreme pH values, etc. The method described in this International Standard is based on the detection of Pseudomonas aeruginosa in a non-selective liquid medium (enrichment broth),
26、followed by isolation on a selective agar medium. Other methods may be appropriate, depending on the level of detection required. NOTE For the detection of Pseudomonas aeruginosa, subcultures can be performed on non-selective culture media followed by suitable identification steps (e.g. using identi
27、fication kits). Because of the large variety of cosmetic products within this field of application, this method may not be appropriate in every detail for some products (e.g. certain water immiscible products). Other International Standards (ISO 18415 10) may be appropriate. Other methods (e.g. auto
28、mated) may be substituted for the tests presented here provided that their equivalence has been demonstrated or the method has been otherwise validated. 2 Normative references The following referenced documents are indispensable for the application of this document. For dated references, only the ed
29、ition cited applies. For undated references, the latest edition of the referenced document (including any amendments) applies. ISO 21148:2005, Cosmetics Microbiology General instructions for microbiological examination EN 12353, Chemical disinfectants and antiseptics Preservation of microbial strain
30、s used for the determination of bactericidal and fungicidal activity 3 Terms and definitions For the purposes of this document, the following terms and definitions apply. 3.1 product portion of an identified cosmetic product received in the laboratory for testing 3.2 sample portion of the product (a
31、t least 1 g or 1 ml) that is used in the test to prepare the initial suspension Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitte
32、d without license from IHS -,-,- ISO 22717:2006(E) 2 ISO 2006 All rights reserved 3.3 initial suspension suspension (or solution) of the sample in a defined volume of an appropriate enrichment broth 3.4 sample dilution(s) dilution(s) of the initial suspension 3.5 specified micro-organism aerobic mes
33、ophilic bacteria or yeast that is undesirable in a cosmetic product and is recognized as a skin pathogen species that may be harmful for human health or as indication of hygienic failure in the manufacturing process 3.6 Pseudomonas aeruginosa Gram-negative rod, motile; smooth colonies pigmented brow
34、n or greenish NOTE 1 The main characteristics for identification are: growth on selective cetrimide agar medium, oxidase positive, production of diffusible fluorescent pigments and production of a soluble phenazine pigment (pyocyanin) in suitable media. NOTE 2 Pseudomonas aeruginosa may be isolated
35、from a wide variety of environmental sources, especially in water and has a very high potential to spoil many different substrates. It may produce infections of human skin or eye area. It is undesirable in cosmetic products for its potential pathogenicity and its capacity to affect the physico-chemi
36、cal properties of the cosmetic formula. 3.7 enrichment broth non-selective liquid medium containing suitable neutralizers and/or dispersing agents and validated for the product under test 4 Principle The first step of the procedure is to perform an enrichment by using a non-selective broth medium to
37、 increase the number of micro-organisms without the risk of inhibition by the selective ingredients that are present in selective/differential growth media. The second step of the test (isolation) is performed on a selective medium followed by identification tests. The possible inhibition of microbi
38、al growth by the sample shall be neutralized to allow the detection of viable micro-organisms 1. In all cases and whatever the methodology, the neutralization of the antimicrobial properties of the product shall be checked and validated 2, 3, 4. 5 Diluents and culture media 5.1 General General instr
39、uctions are given in ISO 21148. When water is mentioned in this document, use distilled water or purified water as specified in ISO 21148. The enrichment broth is used to disperse the sample and to increase the initial microbial population. It may contain neutralizers if the specimen to be tested ha
40、s antimicrobial properties. The efficacy of the neutralization shall be demonstrated (see Clause 11). Information relative to suitable neutralizers is given in Annex B. The following enrichment broth is suitable for checking the presence of Pseudomonas aeruginosa in accordance with this Internationa
41、l Standard provided that it is validated in accordance with Clause 11. Other diluents and culture media may be used if they can be demonstrated to be suitable for use. Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA Technical Standards 1/
42、9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- ISO 22717:2006(E) ISO 2006 All rights reserved 3 5.2 Diluent for the bacterial suspension (tryptone sodium chloride solution) 5.2.1 General The diluent is used for the preparation
43、 of bacterial suspension used for the validation procedure (see Clause 11). 5.2.2 Composition tryptone, pancreatic digest of casein 1,0 g sodium chloride 8,5 g water 1 000 ml 5.2.3 Preparation Dissolve the components in water by mixing whilst heating. Dispense into suitable containers. Sterilize in
44、the autoclave at 121 C for 15 min. After sterilization and cooling down, the pH shall be equivalent to 7,0 0,2 when measured at room temperature. 5.3 Culture media 5.3.1 General Culture media may be prepared using the descriptions provided below or from dehydrated culture media according to the inst
45、ructions of the manufacturer. The instructions provided by the supplier of the media should be followed. NOTE Ready to use media may be used when their composition and/or growth yields are comparable to those of the formulas given herein. 5.3.2 Agar medium for validation (soybeancasein digest agar m
46、edium or tryptic soy agar) 5.3.2.1 Composition pancreatic digest of casein 15,0 g papaic digest of soybean meal 5,0 g sodium chloride 5,0 g agar 15,0 g water 1 000 ml 5.3.2.2 Preparation Dissolve the components or the dehydrated complete medium in the water by mixing whilst heating. Dispense the med
47、ium into suitable containers. Sterilize in the autoclave at 121 C for 15 min. After sterilization and cooling down, the pH shall be equivalent to 7,3 0,2 when measured at room temperature. Copyright International Organization for Standardization Provided by IHS under license with ISO Licensee=NASA T
48、echnical Standards 1/9972545001 Not for Resale, 04/19/2007 19:35:56 MDTNo reproduction or networking permitted without license from IHS -,-,- ISO 22717:2006(E) 4 ISO 2006 All rights reserved 5.3.3 Enrichment broth 5.3.3.1 Eugon LT 100 broth 5.3.3.1.1 General This medium contains ingredients that neutralize inhibitory substances present in the sample: lecithin and polysorbate 80, and dispersing age