《UL-1199-1999.pdf》由会员分享，可在线阅读，更多相关《UL-1199-1999.pdf（32页珍藏版）》请在三一文库上搜索。
1、UL 1199 ISBN 0-7629-0405-4 Recreational Boats Less Than 20 Feet in Length Copyright Underwriters Laboratories Inc. Provided by IHS under license with ULLicensee=North Carolina State University/5618801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license f
2、rom IHS -,-,- Copyright Underwriters Laboratories Inc. Provided by IHS under license with ULLicensee=North Carolina State University/5618801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license from IHS -,-,- Underwriters Laboratories Inc. (UL) 333 Pfi ng
3、sten Road Northbrook, IL 60062-2096 UL Standard for Safety for Recreational Boats Less Than 20 Feet in Length, UL 1199 Second Edition, Dated July 22, 1999 Revisions: This Standard contains revisions through and including September 30, 2002. The revisions dated September 30, 2002 include a reprinted
4、title page (page1) for this Standard. The revisions dated September 30, 2002 were issued to include the missing graphic for Figure 4.1. The master for this Standard at ULs Northbrook Office is the official document insofar as it relates to a UL service and the compliance of a product with respect to
5、 the requirements for that product and service, or if there are questions regarding the accuracy of this Standard. ULs Standards for Safety are copyrighted by UL. Neither a printed copy of a Standard, nor the distribution diskette for a Standard-on-Diskette and the fi le for the Standard on the dist
6、ribution diskette should be altered in any way. All of ULs Standards and all copyrights, ownerships, and rights regarding those Standards shall remain the sole and exclusive property of UL. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or transmitt
7、ed in any form by any means, electronic, mechanical photocopying, recording, or otherwise without prior permission of UL. Revisions of UL Standards for Safety are issued from time to time. A UL Standard for Safety is current only if it incorporates the most recently adopted revisions. UL provides th
8、is Standard as is without warranty of any kind, either expressed or implied, including but not limited to, the implied warranties of merchantability or fi tness for any purpose. In no event will UL be liable for any special, incidental, consequential, indirect or similar damages, including loss of p
9、rofi ts, lost savings, loss of data, or any other damages arising out of the use of or the inability to use this Standard, even if UL or an authorized UL representative has been advised of the possibility of such damage. In no event shall ULs liability for any damage ever exceed the price paid for t
10、his Standard, regardless of the form of the claim. UL will attempt to answer support requests concerning electronic versions of its Standards. However, this support service is offered on a reasonable efforts basis only, and UL may not be able to resolve every support request. UL supports the electro
11、nic versions of its Standards only if they are used under the conditions and operating systems for which it is intended. ULs support policies may change from time-to-time without notifi cation. UL reserves the right to change the format, presentation, fi le types and formats, delivery methods and fo
12、rmats, and the like of both its printed and electronic Standards without prior notice. Purchasers of the electronic versions of ULs Standards for Safety agree to defend, indemnify, and hold UL harmless from and against any loss, expense, liability, damage, claim, or judgement (including reasonable a
13、ttorneys fees) resulting from any error or deviation introduced while purchaser is storing an electronic Standard on the purchasers computer system. SEPTEMBER 30, 2002 UL 1199tr1 Copyright Underwriters Laboratories Inc. Provided by IHS under license with ULLicensee=North Carolina State University/56
14、18801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license from IHS -,-,- If a single-user version electronic Standard was purchased, one copy of this Standard may be stored on the hard disk of a single personal computer, or on a single LAN fi le-server o
15、r the permanent storage device of a multiple-user computer in such a manner that this Standard may only be accessed by one user at a time and for which there is no possibility of multiple concurrent access. If a multiple-user version electronic Standard was purchased, one copy of the Standard may be
16、 stored on a single LAN fi le-server, or on the permanent storage device of a multiple-user computer, or on an Intranet server. The number of concurrent users shall not exceed the number of users authorized. Electronic Standards are intended for on-line use, such as for viewing the requirements of a
17、 Standard, conducting a word search, and the like. Only one copy of the Standard may be printed from each single-user version of an electronic Standard. Only one copy of the Standard may be printed for each authorized user of a multiple-user version of an electronic Standard. Because of differences
18、in the computer/software/printer setup used by UL and those of electronic Standards purchasers, the printed copy obtained by a purchaser may not look exactly like the on-line screen view or the printed Standard. An employee of an organization purchasing a UL Standard can make a copy of the page or p
19、ages being viewed for their own fair and/or practical internal use. The requirements in this Standard are now in effect, except for those paragraphs, sections, tables, fi gures, and/or other elements of the Standard having future effective dates as indicated in the note following the affected item.
20、The prior text for requirements that have been revised and that have a future effective date are located after the Standard, and are preceded by a SUPERSEDED REQUIREMENTS notice. New product submittals made prior to a specifi ed future effective date will be judged under all of the requirements in t
21、his Standard including those requirements with a specifi ed future effective date, unless the applicant specifi cally requests that the product be judged under the current requirements. However, if the applicant elects this option, it should be noted that compliance with all the requirements in this
22、 Standard will be required as a condition of continued Listing and Follow-Up Services after the effective date, and understanding of this should be signifi ed in writing. Copyright 2002 Underwriters Laboratories Inc. This Standard consists of pages dated as shown in the following checklist: PageDate
23、 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . September 30, 2002 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24、 . . . . . . . . . . . . . . July 22, 1999 6-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . September 30, 2002 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
25、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . July 22, 1999 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . September 30, 2002 10-19. . . . . . . . . . . . . . . . . . . . . .
26、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . July 22, 1999 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . September 30, 2002 21-28. . .
27、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . July 22, 1999 SEPTEMBER 30, 2002 UL 1199tr2 Copyright Underwriters Laboratories Inc. Provided by IHS under license with ULLicensee=North Carolina State Un
28、iversity/5618801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license from IHS -,-,- JULY 22, 1999 (Title Page Reprinted: September 30, 2002) 1 UL 1199 Standard for Recreational Boats Less Than 20 Feet in Length First Edition September, 1982 Second Editio
29、n July 22, 1999 An effective date included as a note immediately following certain requirements is one established by Underwriters Laboratories Inc. Revisions of this Standard will be made by issuing revised or additional pages bearing their date of issue. A UL Standard is current only if it incorpo
30、rates the most recently adopted revisions, all of which are itemized on the transmittal notice that accompanies the latest set of revised requirements. ISBN 0-7629-0405-4 COPYRIGHT 1982, 2002 UNDERWRITERS LABORATORIES INC. Copyright Underwriters Laboratories Inc. Provided by IHS under license with U
31、LLicensee=North Carolina State University/5618801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license from IHS -,-,- JULY 22, 1999RECREATIONAL BOATS LESS THAN 20 FEET IN LENGTH - UL 11992 No Text on This Page Copyright Underwriters Laboratories Inc. Prov
32、ided by IHS under license with ULLicensee=North Carolina State University/5618801100 Not for Resale, 10/16/2006 02:51:36 MDTNo reproduction or networking permitted without license from IHS -,-,- CONTENTS FOREWORD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
33、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 INTRODUCTION 1 Scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 2 Units of Measurement . . . . . . . . . . . .
34、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 3 Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 4 Glossary . . . . . . . . . .
35、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8 CONSTRUCTION 5 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
36、 . . . . . .12 RATING 6 Maximum Power Capacity Rating of Outboard Boats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 7 Maximum Weight Capacity Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 7.1 Inboard
37、 and inboard-outdrive boats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 7.2 Outboard boats over 2 horsepower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 7.3 Manual propulsion boats and outboard boats
38、of 2 horsepower or less . . . . . . . . . . . . . . .13 8 Maximum Persons Capacity Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 PERFORMANCE 9 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
39、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 10 Weight and Maximum Displacement Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 10.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
40、. . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 10.2 Weight determination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 10.3 Maximum displacement determination . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
41、. . . . . . . . . . . . .15 11 Maximum Persons Capacity Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 12 Basic Floatation Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42、 . . . . . . . . . .16 13 Flooded Level Flotation and Persons Capacity Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 13.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
43、 .16 13.2 Preparation of boat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17 13.3 Test procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17 14
44、 Flooded Stability Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 14.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
45、 .18 14.2 Preparation of boat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 14.3 Test procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 15
46、 Flotation Materials Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 15.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
47、.19 15.2 Test samples . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 15.3 Sample volume determination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 15.4 Sample b
48、uoyancy determination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 15.5 Solvent exposure test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23 15.6 Environmental exposure tests . . .
49、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 16 Permanence of Marking Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 16.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .