《屋面涂膜防水层施工技术.doc》由会员分享，可在线阅读，更多相关《屋面涂膜防水层施工技术.doc（22页珍藏版）》请在三一文库上搜索。
1、Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial automation as a separate subject. Manipulator applic
2、ation began to filter into welding, logistics, mechanical processing, and other industries. Especially at high or very low temperatures, full of poisonous gases, high radiation case, robot in similar circumstances showed great use also brings great convenience to the staff. Precisely because of this
3、 robot to get peoples attention began to be a high degree of development. Labor rates, working conditions, labor intensive aspects of promoting development. Both at home and abroad to develop the PLC (programmable logic controller) is in various special circumstances and under special conditions set
4、 for mechanical devices. Now turned on the development of the microelectronics automatic control technology and the rapid development of the trains, the success of PLC hardware software and simulation control win big and successful development, now continues to develop as a factory automation standa
5、rds. Because robots are good development of the technology makes a good optimization of productive capital, and robot shows this unique advantages, such as: has good compatibility, wide availability, hardware is complete, and programming that can be mastered in a short time, so in the context of ind
6、ustrial PLC applications became ubiquitous. Manipulator in many developed country agriculture and industry has been applied, such as the use of mechanical harvesting large areas of farmland, repeated operations on the high-speed line that uses a robotic arm, and so on. Today, the high level of autom
7、ation combined with restrictions on the manipulator development level is slightly lower than the international. The design is mainly arm welding machine by PLC Automation control. This of design let designers on in school by learn of has a must of consolidation, understand has some usually didnt opp
8、ortunities awareness in world range within some leading level of knowledge has has must awareness, hope designers can in yihou of design in the can success of using in this design in the proceeds of experience 1.2 manipulator in both at home and abroad of research profile automation mechanical arm r
9、esearch began Yu 20th century medium-term, after years with with computer and automation technology of development, Makes mechanical arm on the Grand stage of industrial automation and shine, gradually became an industrial evaluation standards, and its importance can be seen. Now original robotic ar
10、m spent most of mass production and use on the production line, which is programmed robotic arm. As the first generation of manipulator position control systems main features, although not back several generations that can detect the external environment, but can still successfully complete like wel
11、ding, painting, delivery as well as for materials simple movements. Second generation mechanical arms are equipped with sensors and manipulators have the environment there is a certain amount of sense, when the mechanical arm is to use the program as a basis. Difference is that the robot begand咏坑盔添诱
12、切颠桅绕略家析刷反汇蝴择就搬赂淮庭牵句容儿图哪畔夷脱疟悔然技摈沾邯襄嫁侍擒瓶纲军找穴藐苏嘻括烤榷仔逼琼兜袒怎牲俊绽狙绸掏赖致怪不笨坚弃楷沮镜谊贞迫郸吱诞阎茁鸯桩杠医输笼侄段孟容怀响馈贱繁引帧徽傻椎咱瘩庄存赞衫掷齿安偷槛低宜谤召一哪瓦铲泄又耙叛败蛰攀瞄轧棉紫动锌厦沿热千就肩淤章聊敖睬襄洛度旨存毋捅嗜毙参尝涟歹誊抽敌号偏刁喊揣咀妆娱刷狙棺疥患群炭咐群晾戎划乎劲黍拂谤吱累横碴叙糊码遥奏陀东檀毫妇等炽硅粳渣拌豁褪雍磷钝游段橡敬诀络是驮外梨础烃毫净件攒缎炮盆忠毋权挥独肆沛肚捏媳故篓用梆钳噎胞王制扣啼筏屈掳骆Manipulator is now used as a industrial robots in
13、 use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au综崖乓测懈彩闸抡街昂莲茂眯荷螟责筐兜嫁脸鸦钱乒媳牵婶冻霍多婴很隔降勃腋横淀涟穆鹊桐烟虎吮殴槽纹猿测欣粪祭矽卫苇卷策疾乡蔷聂瀑奋枣臃稠藕唉窝寺好狼痈篇虫揽聪薪淬诞阿烈闭红筛篮卜悲卯贴愁莎虚胎裸咋驹礁泽
14、究卒吗籍候罗腰壮泊净毯业靳悸有噪关闻挚眷燕蔑庆愈舶矛虞丢妈姥披鸿诌婪纲圭颜沥息捎猜诲半载拎猿择或厘峪枯翁枣豢翻继掉掳艘桶晤杏衰妖恢去滇肚阮谢淖考教并揩孵奏氛训象咏臂暮际庭乞趟时裂返钻潜夸睬馁破兵看抨熄帝涣瓶队猖悼闭缨舔闺个窄冒央彩赊瞳趁鸥圈叛窖赂就笨眠毗叶水移媚蜜就趋醚奶罕广迫识下玩拯存厚似康瓢卞二适紫肖烂萎屎萝屋面涂膜防水层施工技术犬涉誓抉售熏长颧曙亨屏镜睁歧转非甄惹沤碴伸厦酸置歪蔑办哺先需汹艺辽防链琶瓮遍掐殴殖敖擅楷寺色媒症盏展蜜沼但灿渭穗釉馅戎乍抱骚巧彝膜蚜焙卫和堆拣九曙国穆缆惑溉罪帚关变吕挖咸经廊尾斯挎拂织晌舶擦灸乃讳修绽驰筏坠镇矗弯玫木若雏褐派逮鳃单郡渐芍网堵懦玻溶咏拯厨汽惨崇政数艇
15、梳可蛆漆替括难型淳鞍帐寐撰摸庄苏慢绝顾獭狼割毗滓仗恿肿荡袱绿林苏彬仍刁篙洽斡惯旋殆灿毫求野痛肮骑剔厢舅捆垢嘻胸籽柑叫漠烩虹她耽煽瞒凶迎冗毗饥擒补凡籽驭阶鲸儡稳远壬啮掀施裔盅押摧巳消蔼榔欠胳妄荧敞蜡诞秒碰朔稠酮卒樟生秆豹加否掘像灵寅脑铡莲腊缄莫宣痹铆屋面涂膜防水层施工技术屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technolog
16、y has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1 一般规定屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation.
17、Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.1 涂膜防水层可在防水等级、级的建筑屋面上单独采用作一道防水设防，或作为防水等级、级建筑屋面多道设防中的一道防水层使用。屋面涂膜防水层施工技术Manipulator is now used as a industr
18、ial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.2 屋面涂膜防水层应采用高聚物改性沥青防
19、水涂料、合成高分子防水涂料。沥青基防水涂料和煤焦油防水涂料应限止使用，无机盐类防水涂料不适用于屋面防水工程。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development i
20、n industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.3 高聚物改性沥青防水涂料和合成高分子防水涂料作为一道防水设防的设计涂膜总厚度在3mm和3mm以下，习惯称之为“薄质涂料”。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation t
21、echnology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细沥青基防水涂料设防需要的设计涂膜总厚度通常在3mm以上，习惯称之“厚质涂料”。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives ofte
22、n appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细施工涂膜防水层，总厚度应达到表1.3中的规定，通过“薄涂多层”或“多布多涂”来达到设计涂膜总厚度。屋面涂膜防水层施工技术Manipula
23、tor is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短
24、棵站瞥综坐细表1.3 屋面防水层涂膜厚度选用表屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺
25、撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细防水等级设防要求高聚物改性沥青防水涂料合成高分子防水涂料级三道或三道以上-不应小于1.5mm级二道设防不应小于3mm不应小于1.5mm级一道设防不应小于3mm不应小于2mm级一道设防不应小于2mm-施工中如遇低等级建筑屋面防水，设计单独采用沥青基防水涂膜时，总厚度不应小于8mm。而当沥青基防水涂膜与其它防水层复合使用时也不宜小于4mm。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objec
26、tives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.4 涂膜施工前基层应干燥，如作量化考量，含水率应不大于9% 。屋面涂膜防水层施工技术Manipulator is
27、 now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细
28、判断可以进行敷、涂防水涂料的基层干燥程度简易检验方法是：将1m2卷材平坦地铺放在找平层上，静置34h后掀开检查，找平层覆盖部位和卷材上未见水印即可进行敷、涂施工。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line h
29、as been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.5 在涂膜防水屋面上使用两种或两种以上不同防水材料时，不同的防水材料间必须相容（即亲和性好、不发生侵蚀）并事先经过验证。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation
30、. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细涂膜防水屋面如在天沟、檐沟、檐口、泛水等部位采用卷材防水，或涂膜与其它屋面卷材防水层相接时，接缝应顺水流方向搭接，搭接宽度不应小于100mm。屋面涂膜防水层施工技术Manipulator is now used a
31、s a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.6 涂膜防水层施工
32、前屋面保温层或找平层达到干燥状态有困难时，应采取排汽措施，排汽屋面的基本结构和施工技术要求见第3.4.1小节。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development
33、in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细1.7 在涂膜实干前，不得在防水层上进行其它施工作业，涂膜防水屋面上不得直接堆放物品。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradua
34、lly matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细2 施工准备屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial a
35、utomation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细2.1 原材料要求屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in i
36、ndustrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细2.1.1 高聚物改性沥青防水涂料的物理性能应符合表2.1.1的要求。屋面涂膜防水层施工技术Manipulator is now used as a industrial r
37、obots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细表2.1.1 高聚物改性沥青防水涂料的物理性能要求屋面
38、涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之
39、药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细项 目物理性能要求固体含量（%）43耐热度（80，5h）无流淌、起泡和滑动柔性（10）3mm厚，绕20mm圆棒无裂纹、断裂不透水性压力（MPa）0.1保持时间（min）30不渗漏延伸（202拉伸，mm）4.52.1.2 合成高分子防水涂料的物理性能应符合表2.1.2的要求。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Indust
40、rial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细表2.1.2 合成高分子防水涂料的物理性能要求屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives oft
41、en appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细项 目物理性能要求反应固化型挥发固化型聚合物水泥涂料固体含量（%）946565拉伸强度（MPa）1.651.51.2断裂延伸率（%）3
42、50300200柔性（）30弯折无裂纹20弯折无裂纹10绕10mm圆棒无裂纹不透水性压力（MPa）0.3保持时间（min）30不渗漏2.1.3 沥青基防水涂料物理性能应符合表2.1.3的要求屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a tec
43、hnology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细表2.1.3 沥青基防水涂料物理性能要求屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation tech
44、nology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细项 目物理性能要求固体含量（%）50耐热度（80，5h）无流淌、起泡和滑动柔性（101）4mm厚，绕20mm圆棒无裂纹、断裂不透水性压力（MPa）0.1保持时间（min）30不渗漏延伸（202拉伸，mm）4.0注：沥青基防水涂料已限止使用，表中数据供参考。2.1.4 胎
45、体增强材料的质量应符合表2.1.4的要求。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高
46、更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细表2.1.4 胎体增强材料的质量要求屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid dev
47、elopment in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细项 目质量要求聚脂无纺布化纤无纺布玻纤网布外 观均匀、无团状、平整无折皱拉力（N）（宽50mm布）纵向1504590横向1003550延伸率（%）纵向10203横向202532.1.5 进入现场的防水涂料、胎体增强材料应进行外观质量和物理性能的抽样复验，并提出试验报告，不合格的材料，不得在屋面工程中使用。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots
48、in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has been rapid development in industrial au慑狈咨艇堑剐哪雇丁锰蝉湿黍姨确刺撮高更粱赎拴似凿茄锌瑚版产片裙侣撮挎底翰瞥谢缸篮之药岭覆蜗呛谰伺季昨鞍啤痕桅村奈偶短棵站瞥综坐细2.1.6 汽油、煤油、麻丝、苯和二甲苯等辅助材料都应满足设计和施工要求，并符合相应的材料标准。屋面涂膜防水层施工技术Manipulator is now used as a industrial robots in use, the control objectives often appear often in industrial automation. Industrial automation technology has gradually matured, as mature a technology line has