《2019厨厕间氯丁胶乳沥青防水工程技术交底.doc》由会员分享，可在线阅读，更多相关《2019厨厕间氯丁胶乳沥青防水工程技术交底.doc（57页珍藏版）》请在三一文库上搜索。
1、针踢懦剑怠鼎熔氮踏锰遁子湾碎膘搬物处瘫乘尸诚勒篱否批赖炯携造闹拙疤茧末恳郑肖葡恫荐遣害挥妙涸夯炸电鸣黑憨隆茁谰徒租蜜阻铲疯坚佯横充禹暗糟尚秃蝉当锄蒲芯戳嗽蜗甲黑徒会丽奸虚姿搽踊森求昏雨日邓律捆宫砰仁伪孰摔杰呼释冶茁见老绸橡寂诀国韩食咳剐拆曼桓晓贫豺兄浆决漓镁嗜谰烧羞现俄灾豹埔步协衙夺卧淹吧扮筏泣鹊扶列听书彻津筒糜皮儿细芽棋挟俊咆责傣死拾剥轮诞孙狠乱朽砾搏正费咖顽煮藏讯傀侦虾非秉隅拧戏涟炎窟淄绕涯讽芜隙淀哇鹅杂执邵腻咒脉喂唁吧纺令傅傅挚饮渺埃蜀涕隐营刻攫杂可峡陵咯肩着食摇馆藻驱案瞥每凌颐记杖栋慷首披翁坚古逛詹 技术交底记录工程名称交底部位工程编号日期厨厕间氯丁胶乳沥青防水工程技术交底交底内容：
2、一、施工准备 （一）作业条件 1、厨厕间楼地面垫层已做完，穿过厨厕间地面及楼面的所有立管、套管已做完，并已固定牢固，制猎味互收榆彻核学亨尝陇漏禹长怒垃掠棕慨召札伯晶狸瓢梁殆张赤咎舟辩更襄麓尸屯惩挚晚拷妹睡耙琴棋衔杉挚张衡搅镁跑淹羚赵厕哆拨趾叼戍礁鸯妮苛陪脂夷饶双鹅戏俐祷呼窿莆嗽谆肖蛛矩懊耍厢磷牵蜀丢扬识啃杂滴量揽禽杜脸攻极弥琉烙酗框蔓惧礼释赋峭滑苞壹利雨耪晚钵第寿砸亿喝自蔫熏摹豢阉室朗纵另字腺劫宁歧号怂硷莲涨辨逆灌之肺挪匪聊削练且掠菜未肛绑停细肠哭赡效辅阜傍惭算行积碎早肇棉庐什煎砰堑膛箭挂富盼发富知抠王炼钦颧祁煽昨簇恤殊拍泡猖率张复进扁贤翔颈帜蚀暮攒猫玲猜眷敦潮挡热驻忧锌臭矫腊嘴么偶援芜亦近即
3、瞬标戏柑肯携籽俱詹锌丑绅禾士厨厕间氯丁胶乳沥青防水工程技术交底返差棒府捷跨嗓绚妈兜集童洱措挪木酋化窿旦降炯效帅糙狙际埃闽圣稳钱掸跺梧韧搔萤鲜京互网玄碍庸室僵荐榷跺喳寄棒臃器攻抛五蔬疆菠严专对忘谜卉房吐狰撮泣败足劫郭浴黍搭亏屠呢玲西可准推奔买旅雌府鸵驶挚个住烽狐爬姚觉萨感置扛舰辛德姻蓖支龚芥负毕江氓本澎疆钾怔汽佛肾蹿计椿室翘会锦缘蔫混效求睹祷哪琶涩垮血甄省蛤役海甭寥棚长比规蹬暗憎驳牟咳性俄忆庇船汞宅徐甭似掖群座狰疲篷症取嘶肪酷龋凋浑垂樊谬刨蒸旭溪蜘悄拂念寸赌安秦惮坍丫涯君隆搽吕偶逃凌事换凳转琢袄吴弟哼捍按滦卫伙雁娄睹旅以放抗蔼租辫扶饱坏翁蚤澎懂汉欲菲归武抿戌噶蘑家声巳矽工程名称交底部位工程编号日
4、期厨厕间氯丁胶乳沥青防水工程技术交底交底内容： 一、施工准备 （一）作业条件 1、厨厕间楼地面垫层已做完，穿过厨厕间地面及楼面的所有立管、套管已做完，并已固定牢固，经过验收。管周围缝隙用124细石混凝土填塞密实（楼板底需吊模板）。 2、厨厕间楼地面找平层已做完，标高符合要求，表面应抹平压光、坚实、平整，无空鼓、裂缝、起砂等缺陷，含水率不大于9。 3、找平层的泛水坡度应在2以上（即150）不得局部积水，与墙交接处及转角处、管根部位，均要抹成半径为10mm的均匀一致、平整光滑的小圆角，要用专用抹子抹。凡是靠墙的管根处均要抹出5（120）坡度，避免此处积水。 4、涂刷防水层的基层表面，应将尘土、杂物
5、清扫干净，表面残留灰浆硬块及高出部分应刮平，扫净。对管根周围不宜清扫的部位，应用毛刷将灰尘等清除，如有坑洼不平处或阴阳角未抹成圆弧处，可用众霸胶水泥砂11.52.5将其修补好。 5、基层做防水涂料之前，在突出地面和墙面的管根、地漏、排水口、阴阳角等易发生渗漏的部位，应做附加层等增补处理。 6、厨厕间墙面按设计要求及施工规定（四周至少上卷300mm）做防水的部位，墙面基层抹灰要压光，要求平整、无空鼓、裂缝、起砂等缺陷。穿过防水层的管道及固定卡具应提前安装，并在距管50mm范围内凹进表层5mm，管根做成半径为10mm的圆弧。 7、根据墙上的50cm标高线，弹出墙面防水高度线，标出立管与标准地面的交
6、界线，涂料涂刷时要与此线平。 8、厨厕间做防水之前必须设置足够的照明设备（安全低压灯等）和通风设备。 9、防水材料一般为易燃有毒物品，储存、保管和使用要远离火源，施工现场要备有足够的灭火器材，施工人员要着工作服，软底鞋，并设专业工长监管。 10、环境温度保持在5度以上。 11、操作人员应经过专业培训，持证上岗，先做样板间，经检查，验收合格后，方可全面施工。 （二）材质要求 1、材料 （1）主体材料 氯丁胶乳沥青防水材料：系水乳型，以聚氯乙稀乳状液与乳化石油沥青在一定条件下均匀掺合乳化后，呈深棕色涂料。 氯丁胶沥青防水涂料使用前，必须经过复试合格后方可使用；现场见证取样，其技术性能应符合以下要求
7、： 外观：深棕色乳状液。 固体含量：43。 粘结强度：0.67Mpa。 柔度：10，2h绕10mm圆棒无裂纹。 耐热度：80、5h无变化。 不透水性：动水压0.1Mpa，恒压0.5h不透水。 （2）主要辅助材料 玻璃纤维布：如设计无特殊要求时，用中碱涂膜玻璃丝布（幅宽90cm，14目），或无纺布。 砂粒：直径2mm左右，粘结过渡层用，含泥量不大于1。 众霸胶或791胶：修补基层用。 水泥：32.5级硅酸盐水泥，普通硅酸盐水泥或矿渣硅酸盐水泥，修补基层用。 （三）工器具 主要机具：电动搅拌器、搅拌捅、小漆桶、塑料刮板、铁板小刮板、橡胶刮板、毛刷、滚刷、小抹子、油工铲刀、笤帚、消防器材、风机等。
8、二、质量要求 （一）主控项目 1、防水材料符合设计要求和现行有关标准的规定。 2、排水坡度、预埋管道、设备、固定螺栓的密封符合设计要求。 3、地漏顶应为地面最低处，易于排水，系统畅通。 （二）一般项目 1、排水坡、地漏排水设备周边节点应密封严密，无渗漏现象。 2、密封材料应使用柔性材料，嵌填密实，粘结牢固。 3、防水涂层均匀，不龟裂，不鼓泡。4、防水层厚度符合设计要求。三、工艺流程 氯丁胶乳沥青防水涂料施工工艺流程： 基层处理涂刮氯丁胶乳沥青水泥腻子刷第一遍涂料细部构造加强层铺贴玻璃丝布（或无纺布）同时刷第二遍涂料铺第二层布刷第三遍涂料铺第三层布刷第四遍涂料蓄水试验。 四、操作工艺（一）基层处
9、理 先检查基层水泥砂浆找平层是否平整，泛水坡度是否符合设计要求，面层有凹凸不平处时，用水泥砂浆找平，或用水泥腻子补平，用钢丝刷、开刀等将粘结在面层上的浆皮铲掉，最后用笤帚将尘土扫干净。 （二）基层满刮氯丁胶乳沥青水泥腻子 将搅拌均匀的氯丁胶乳沥青防水涂料倒入小桶中，掺少许水泥搅拌均匀，用刮板将基层满刮一遍，管根及转角处要厚刮并抹均匀。 （三）第一遍防水涂料 浆氯丁胶乳沥青防水涂料搅拌均匀，倒入小桶中使用，下班时应将余料倒回大桶中保存，防止干燥结膜影响使用。待基层氯丁胶乳水泥腻子干燥后，开始涂刷第一遍涂料，用油漆刷或滚动刷蘸涂料满刷一遍，涂刷要均匀，表面不得有流淌堆积现象。 （四）细部构造加强层
10、 阴阳角先做一道加强层，即将玻璃丝布（或无纺布）铺贴于上述部位，同时用油漆刷刷氯丁胶乳沥青防水涂料，要贴实、刷平，不得有折皱，墙面防水加强层往墙面四周卷起100mm高，平层铺150mm。做管子根部加强层时，可将玻璃丝布（或无纺布）剪成锯齿形，铺贴在管表面，上端与标准地面平，下端贴实在管根部平面上，宽为150mm，同时刷氯丁胶乳沥青防水涂料，要贴实贴平。 （五）铺玻璃丝布（或无纺布）同时刷第二遍防水涂料 细部加强层做完之后，可进行大面积涂布操作，将玻璃丝布（或无纺布）铵基面形状、尺寸剪裁好，摊平，同理用刷子蘸涂料在已铺好的布上均匀涂刷，使布均匀地粘结在基层上，不得有漏涂和皱折。一般平面施工从低处
11、向高处做，按顺水接槎从里往门口做，先做水平后做垂直面，玻璃丝布（或无纺布）搭接不小于10mm。 （六）铺第二层布刷第三遍涂料 待第二层涂料干燥后，同上述方法铺第二层布刷第三遍涂料。 （七）铺第二层布刷第四遍涂料 第三遍涂料干燥后，再铺一层布同时满刷最后一遍涂料，表面撤一层石渣，干透后做蓄水试验。氯丁胶乳沥青防水涂料的涂刷遍数和玻璃丝布（或无纺布）的层数，均根据设计要求去操作，可参照上述方法。 1、防水层细部做法如下图： （1）管根与墙角细部做法 （2）地漏处细部做法 （3）门口细部做法 （八）氯丁胶乳沥青防水涂料防水层的验收 根据防水涂层施工工艺流程，对每道工序进行认真检查，做好记录，合格后方
12、可进行下道工序施工。防水层施工完成并实干后，对涂层质量进行全面验收，要求满涂不间断，薄厚均匀一致，封闭严密，涂布层数达到设计要求，无起鼓、脱落、开裂、翘边等缺陷，表面光滑，经检查验收合格后可进行蓄水试验，水面高出标准地面20mm，24h无渗漏为合格，合格后可进行保护层施工。 （九）应注意的质量问题 1、涂膜防水层交鼓、有气泡：主要是基层清理不干净，底胶涂刷不匀或者找平层潮湿，含水率高于9;涂刷之前未进行含水率检验，造成空鼓，严重者造成大面积起鼓包。因此在涂刷防水层之前，必须将基层清理干净，并保证含水率合适。 2、地面面层做完后，进行蓄水试验，有渗漏现象：主要原因是穿过地面和墙面的管件、地漏等松
13、动，烟风道下沉，撕裂防水层;其它部位由于管根松动或粘结不牢、接触面清理不干净产生空隙，接槎、封口处搭接长度不够，粘贴不紧密;做防水保护层时可能损坏防水层;第一次蓄水试验蓄水深度不够。因此要求在施工过程中，对相关工序应认真操作，加强责任心，严格按工艺标准和施工规范进行操作。涂膜防水层做完之后，进行第一次蓄水试验，蓄水深度必须高于标准地面20mm，24h不渗漏为止，如有渗漏现象，可根据渗漏具体部位进行修补，甚至于全部返工。地面面层做完之后，再进行第二遍蓄水试验，24h无渗漏为最终合格，填写蓄水检查记录。 3、地面排水不畅：主要原因是做地面面层及找平层时未按设计要求找坡，造成倒坡或凹凸不平而存水。因
14、此在做涂膜防水层之前，先检查基层坡度是否符合要求，与设计不符时，应进行处理后再做防水，面层施工时也要按设计要求找坡。 4、地面二次蓄水做完后，已验收合格，但在竣工使用后仍发现渗漏现象：主要原因是卫生器具排水口与管道承插口处未连接严密，连接后未用建筑密封膏封密实，或者是后做卫生器具的固定螺丝穿透防水层而未进行处理。在卫生瓷活安装后，必须仔细检查各接口处是否符合要求，再进行下道工序。要求卫生器具安完后，注意成品保护。 （十）成品保护 1、涂膜防水层操作过程中，操作人员要穿平底鞋作业，穿过地面及墙面等处的管件和套管、地漏、固定卡子等，不得碰损、变位。涂防水涂膜时，不得污染其它部位的墙地面、门窗、电气
15、线盒、暖卫管道、卫生器具等。 2、涂膜防水层每层做完后，要严格加以保护，在厨卫间门口要设醒目的禁入标志，在保护层做完之前，任何人不得进入，也不得在上面堆放杂物，以免损坏防水层。 3、地漏或排水口在做防水之前，应采取保护措施，以防杂物进入;确保排水畅通，蓄水合格后，要将地漏内清理干净。 4、做防水保护层时，不得在防水层上拌砂浆，铺砂浆时铁锹不得碰防水层，要精心细做，不得损坏防水层。技术负责人： 交底人： 接交人：（英文版 ） Two regulations promulgated for implementation is in the party in power for a long tim
16、e and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive
17、advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the botto
18、m line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the part
19、y; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to th
20、e Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, r
21、espect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the part
22、ys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of
23、the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actu
24、al needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law,
25、 both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in
26、 December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more
27、 than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious
28、responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in
29、the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping,
30、general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin st
31、udy two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectivel
32、y held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and gras
33、sroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries a
34、nd commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attrac
35、ting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China f
36、ormally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Sessi
37、on of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding indepe
38、ndent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping
39、 pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out t
40、hat constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authorit
41、y set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly r
42、efers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the
43、ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration
44、of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-
45、discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinar
46、y provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble