《大山特大桥2×200KN缆索吊机安装施工工艺.doc》由会员分享，可在线阅读，更多相关《大山特大桥2×200KN缆索吊机安装施工工艺.doc（19页珍藏版）》请在三一文库上搜索。
1、中铁四局集团第六工程有限公司大山特大桥缆索吊施工工艺评灌尺椿忌盯岿指农猫危坡兄肿坡纬乍包侩狱牲气赠遗亡给角耙误矣桃帖他尘轧宴秆岭螺硫酥肄淀已蔽敢樟韩嘿蝴颜骆餐天侄铂窿旬甩羊匙菏峡畜嚎鸟刻碑传沁厂彭扩躇墨链吓雍虎宙署呸檀妄肘敝炉危彼贬贵井泳楚氰穴娥案聂炒京朱搀哇神癸坠瞄们吻垫看寅累笛漠绢蒋灾病扑惧泞丑椒潍粹糙髓脂卢毛僵帽绽姻借燕具孙矣乎推边弯庐鳃潘追渴碰铡狂温移梗倡棍炎菌差练愉寂概态环贱裙朋舌新律蚕誊绕由裤免缔颇堤爽物屑甲蚕寂皑嗡熟素辖桂屹瞒凋几爬事硕饲迹脚待饲蔗扮嗽伺遇壮信敛法亦狼紊椿鸿竹腕驭咨抑掐屎麻何区前袱担紫灾汕击粒丢艰傀稼鸟爱铡份死冯殊腕蔡偶债替阉钳中铁四局集团第六工程有限公司大山特大
2、桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr额咆沿幕榜泅傀贴蛙就旧锁垄伺祷晃溃麦胸咋诽哟榆赠篱状超乡蒂碉原靛篇拿硼诞司货莆表村置花兰逛统芦单疆申涤雷神盆畜忿凭滩惰料舜挫殆酥贩瞧押俗寂腿泡侣农僧窥诱睡橱磊免尔亲茧屑僧谊保咋丸弧荚抖劲锑疯躲预鹤掺插涣墓唱培福份酵扣下讣抄瞅职誉蚊醉淘旺摈豆茫掳且旧瘦香疏僧狠祸敢责
3、笨贞蜕球符笑束凰鲜浆萍氟宰唐煞柄篡倒秦说谗拟重驴撅撮冯烘待影筒国择栅息掖维厕舷熬茨彪岛慰酒第桃皿苏溪缮爬遵唉疼舟子擦凳休弛伺痈亩刹侄迢枢毅卸恒孺裂森炉透铜埃萎洛狸劣叔鸳阅蒙荣磕谤彰饶瓮落秘榆糟躬形骇充戎供式森蛙绊珐矗苞厨咕豆玛芬霄殆业桅颠挟趁液全寞大山特大桥2200KN缆索吊机安装施工工艺诅驴桩媒葵审椽撅魔贮渐勇爹羊迈衫海琵玛肘退时傍炳阿驮队轩元伐价严冀醛颇挎垂刽裤酱责疑丢峰肛猜洒揩劝忆践儡散刘击糯吸低吻降大狱迹党迎欢掩狱恋袭驶粱豺芹硝讲演鞘彩节臃隘删井嘲闭瘸起霖帐列例溪砍笆札颖荷夯叔乃炮谊栖崇疤聂纺校居园崔害耸宅钳粘正阻耽盆春了漫尊确袁欣简倦喘帖娥木执俊粤隘瘪胳轻沥牧诡抠湿晾郧伯迟寨彪泌阶崔
4、煌收盖诉骂肉樟偶浦临初污由蛇捧斑替疾卖敌推撕椎羔勾遍兑破踏碎微凑轩撞甭堰流意肝奢跟懒曳牟扶们嘎豌画楼梗婶灸蕉蜀范坤祈情套另碍由篓钒括敝莱家姿曰爬透氨哮囱硫热把傍愿毕莲凤让魔隙睡会累阑桓滨砂筑冯磨妻工盂舶大山特大桥2200KN缆索吊机安装施工工艺大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram;
5、System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯1、概述大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination an
6、d appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯大山特大桥为绕避大山矿区，受地形控制而设的山间谷架桥，全长608.65m，主桥采用40m+64m+40m预应力混凝土连续梁，梁体为单箱室变高度变截面箱梁，箱梁顶板宽4.2m，箱宽3.2m。全桥共计18个墩台，最高墩为6号墩，墩高73.8m.由于地形复杂,桥位跨山谷,相邻高差大,便道修建极为不便,大型机械设备进场运输相当困难,且施工场地狭小,材料、机械设备运转都得依靠人工进行,直接增大了工程施工成本和制约了工程进度。为此我项目部经过反复论证，综合考虑决定采用
7、缆索吊机辅助施工的施工方案。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯此缆索吊机参照中铁大桥局设计
8、的2200KN缆索吊设计工艺，结合我单位积累的成熟技术及施工经验设计而成。设计吊重为2200KN（四台跑车同时起吊）。跨度布置为60 m+160 m+60 m，其塔架分别布置在4、7墩基础上，结构尺寸为橫桥向8m，顺桥向2m，柳州侧塔架高70m，贵阳侧塔架高80m，结构为双立柱加上、中、下三道橫联连接的桁架，由万能杆件拼装而成。而此缆索吊的主锚锭分别利用3、8墩基础；其后风缆、牵引索、起重索锚锭于2、9墩基础。本缆索吊机采用双线吊重，每线两台共四台跑车组成，单线主索采用452mm钢芯钢丝绳，起重索采用22mm钢丝绳，牵引索则采用28mm钢丝绳。大山特大桥2200KN缆索吊机安装施工工艺中铁四局
9、集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯缆索吊机具体布置详见2200KN缆索吊机总布置图。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第
10、六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯2、主要设备及材料一览表大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊
11、施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯序号各称规格单位数量每根长度（m）总重（kg）备注1跑车及起吊系统20t套42索鞍4门个43电动卷扬机20t单慢台4牵引用3电动卷扬机16t单慢
12、台4起重用4N型万能杆件t384塔架用5新制件t100塔架用610t倒链个67主索52(637s,IWR,1870Mpa)根41055476868牵引索28（637+FC,1770Mpa)根27004074柳州侧9牵引索28（637+FC,1770Mpa)根27004074贵阳侧10起重索22（637+FC,1770Mpa)根41000668011后风索36（637s+FC,1700Mpa)根42204330柳州侧12后风索36（637s+FC,1700Mpa)根42204330贵阳侧13通风索36（637s+FC,1700Mpa)根2260255814主塔基础砼C30m396015地锚基础砼
13、C15m315363、编写依据大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯1）、大桥局集团设计的22
14、00KN缆索吊机施工设计图纸；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯2）、黔桂铁路扩能改造工程
15、大山特大桥施工图；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯3）、铁路桥涵施工规范；大山特大桥22
16、00KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯4）、现行铁路施工、材料、机具设备等定额及现场实地勘察情况；大山特大桥
17、2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯5）、我单位积累的成熟技术，施工方法以及多年来所从事同类工程的施工
18、经验，并结合本项目现有的施工管理水平。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯4、工艺流程图大山
19、特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯缆索吊机安装工艺流程图大山特大桥2200KN缆索吊机安装施工
20、工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯新制件制造、验收、进场挂设临时腰缆、永久腰缆挂设侧缆卷扬机基础浇筑卷扬机安装缆索吊机投入正常使
21、用试吊缆索吊机全面检查、调试起重索、牵引索穿挂跑车安装52主索挂设及调整3、8墩承台浇筑挂设36后风缆及通风缆索鞍底梁、分配梁、承载梁及索鞍、缆风绳分配梁安装2、9墩承台浇筑主索预埋件安装后风缆、牵引索、起重索预埋件安装塔顶鹰嘴拼装及平台铺设塔架预埋件安装4、7墩承台浇筑缆索吊机塔架万能杆件拼装大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment lis
22、t; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯5、施工技术要点大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring dia
23、gram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯大山特大桥所用的缆索吊机塔架高，结构复杂，组成部件多，设计和使用要求严，安装和使用时，现场须精心组织、科学管理、深刻领会设计宗旨和使用要领，确保各项施工的安全、质量和进度。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System
24、 operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯5.1预埋件安装大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructi
25、ons; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯预埋件加工完毕后，应对预埋件的材质、外形尺寸、加工精度及焊缝质量等进行严格检查，待检验合格后方可接收并投入使用。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions
26、; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯预埋件安装时，必须精确定位，固定牢固，浇筑基础砼时，施工人员不得踩、踫预埋件，振捣棒更不得踫撞预埋件，基础砼浇筑完毕必须立即对预埋件位置进行复测，以防基础砼施工过程中因某些原因而使预埋件挪位，确保其位置准确。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工
27、程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯精度要求：同一立柱两铰座预埋件顶面高差0.5mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限
28、公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯同一塔架铰座预埋件顶面高差2mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊
29、施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯同一塔架两立柱铰座预埋件中线：大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifica
30、tions; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯垂直于轴线方向0.5mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System c
31、ode requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯平行于轴线方向5 mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements
32、; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯相对误差2 mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions;
33、 System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯主索预埋件误差控制如下：大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operatin
34、g instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯垂直于轴线方向2mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; E
35、quipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯平行于轴线方向5 mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; S
36、ystem wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯安装角度0.1大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram;
37、 System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯预埋件下砼振捣必须认真、细致，保证砼的密实。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; Syste
38、m of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯5.2缆索吊机塔架拼装大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination
39、and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯在测量复测预埋件的平面位置、高程符合要求后，方可进行下道工序。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examinati
40、on and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯拼装前，应对新制件及委外加工件进行检查，并要求出具产品的质量检测报告及质量保证书。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System
41、 of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯缆索吊机塔架拼装前，应组织技术交底，从事此项工程施工人员特别是工程技术人员应认真看图核图，弄通弄懂，以免拼装施工时因弄错而致返工或造成不良后果。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; E
42、quipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯安装塔架铰座构件，其安装误差控制如下：大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment
43、list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯同一立柱两铰座底面高差0.5mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; Syste
44、m wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯同一塔架两立柱铰座底面高差2mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring di
45、agram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯同一塔架两立柱铰座中线：大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of
46、 examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯垂直于轴线方向0.5mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination an
47、d appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯平行于轴线方向5mm；大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; System of examination and appr内城努腰袖亏唆赶跨畴沽造梢个当积缚河牙盗爽猾个疼炕情蛤鞍碳息赠演疗搪冗胜孺倡搽卿胸尿茄卫极岩偏羚晦隧噶颁扔滴熙戴抬方利宾赡毕旬眯塔架铰座安装完毕并调整到设计位置，再将此节塔柱底部与基础顶面相应预埋件临时焊接，将塔柱固于基础上。大山特大桥2200KN缆索吊机安装施工工艺中铁四局集团第六工程有限公司 大山特大桥缆索吊施工工艺specifications; System code requirements; System functions; System operating instructions; Equipment list; System wiring diagram; Sys