《《胶粉聚苯颗粒内墙保温组织设计》.doc》由会员分享，可在线阅读，更多相关《《胶粉聚苯颗粒内墙保温组织设计》.doc（11页珍藏版）》请在三一文库上搜索。
1、胶粉聚苯颗粒内墙保温施工方案 编制：_ 审核：_ 审批：_陕西卓翼节能材料工程有限公司施工进度与质量安全控制（一）施工进度和质量安全控制1、根据土建方的工程进度，安排一支高质量的施工队伍，在甲方要求的工期内，保质保量的完成施工任务。2、严格按照现行有关技术规程组织施工，规范化管理，程序化施工，确保工程质量。3、组织施工技术员、施工员、质量员认真学习有关规范及工艺标准，严格执行施工质量管理制度，教育工人把质量第一的思想贯穿到施工的全过程中。4、建立三级管理制度，加强“三检”（自检、互检、专职检），实行岗位责任制。5、实行创优工程目标管理，明确施工与验收目标，进行样板引路，保证实现目标。（二）文明
2、施工及安全防范1、建立现场施工责任制及保洁区管理制度。2、各种材料设备根据工程进度有序进入工地，避免盲目进场或后用先进情况，材料堆放整齐规范。3、施工场地要保持清洁干净，坚持做到工完场清。4、建立建全生产责任制，明确各级施工人员的安全职责。5、做好工人入场安全教育，执行现场各项安全管理制度。6、施工人员进入现场必须戴安全帽，脚手架要随时检查，发现问题立即采取措施纠正。7、 电动机具实行“一机、一用、一漏、一箱”。二、施工技术规程1、总则 1.1为了贯彻国家节能政策及民用建筑节能设计标准(采暖居住建筑部分)用建设部民用建筑节能管理规定76号部长令，为保证施工做法统一，保证施工质量、做到技术先进、
3、经济合理，特制定本规程。 1.2本规程规定了胶粉聚苯保温材料体系在外墙内保温工程中的做法，适用于建筑混凝土和各类砌体、结构外墙外保温。 1.3外墙内保温层厚度应符合民用建筑节能设计标准（采暖居住建筑部分）的规定，并由设计按要求确定。4除遵守本规程外，尚应符合国家及陕西省有关标准规定。2、术语2.1胶粉聚苯保温材料由胶粉料与聚苯颗粒组成，两种材料分袋包装。使用时按比例加水搅拌而成。2.2柔性抗裂砂浆：由外加剂配制而成的抗裂剂与水泥、中细砂按一定重量比搅拌均匀而成。3玻纤网格布：由耐碱玻璃纤维构成，与抗裂砂浆配套使用，用于提高保温体系的抗裂能力与抗冲击能力。2.4复合胶粉聚苯外墙内保温体系。由界面
4、砂浆层、胶粉聚苯颗粒保温层、玻纤网格布、柔性抗裂砂浆组成保温构造系统，内饰面适用于内墙涂料。3、施工准备 3.1材料3.1.1 胶粉聚苯颗粒保温材料应满足表3.1.2性能胶粉聚苯颗粒保温材料性能指标 表3.1.2项目单位指标密度Kg/m3230导热系数W/m.k0.06拉伸粘接强度Kpa100压减粘接强度Kpa50抗折强度Kpa0.4耐火率/B1 级线性收缩率%0.33.1.2聚苯颗粒应满足以下性能要求聚苯颗粒性能指标 表3.1.3项目单位质量堆积密度Kg/m3810粒度（3mm筛孔筛余）%33.1.3 柔性抗裂砂浆应满足以下性能指标柔性抗裂砂浆性能指标 表3.1.4项 目单 位指 标可操作时
5、间H2拉伸粘结强度（常温28d）Mpa0.8浸水粘结强度（常温28d，浸水7d）Mpa0.6抗弯曲性 /5%弯曲变形无裂纹渗透压力比%200压折比（抗压强度/抗体强度）/3 3.1.4玻纤网格布应满足下表的性能指标，见附表耐碱玻纤网格布性能指标 表3.1.5项目单位指标网孔中心距普通型mm44加强型66单位面积质量普通型g/m2160加强型500断裂强力（经、纬向）普通型N/50mm1250加强型3000耐碱强力保留率（经、纬向）90涂塑量g/m220玻璃成份符合JC719的规定，其中 ZrO214.5，TiO2为60.53.1.5胶粉聚苯保温材料系统应满足下表性能指标胶粉聚苯保温材料系统性能
6、指标 表3.1.6项 目单 位指 标耐候性/经80次高温降雨循环和20次加热冷冻循环后不得出现开裂、空鼓或脱落。抹面层与保温层的拉伸粘结强度应不小于0.1M pa , 破坏界面应位于保温层。吸水量G/1000抗冲击强度T3.0抗风压值Kpa不小于工程项目的风荷载设计值耐冻融/表面无裂缝、空鼓、鼓包、剥离现象不透水性/试样防护层风侧无水渗透耐磨损500（细砂）/无开裂、龟裂或表面剥落、损伤抗震性能/遭遇地震下外保温体系无脱落3.2施工条件及工具3.2.1 基层墙体应符合混凝土结构工程施工质量验收规范（GB50204-2002）和砌体工程施工质量验收规范（GB50203-2002）的要求。3.2.
7、2门窗框及墙身上各种进户管线、水落管支架、预埋管件等按设计安装完毕。3.2.3施工环境温度不应低于5，风力不应大于5级，风速不宜大于5m/s。严禁雨天施工，雨期施工应做好防雨措施。3.2.4施工工具主要有强制式砂浆搅拌机、手提式搅拌机、垂直运输机械、手推车、专用检测工具、放线工具、剪刀、滚刷、铁锨、手锤、托线板、靠尺、钢尺、壁纸刀等。3.3材料配制3.3.1水泥 选用强度等级为42.5普通硅酸盐水泥，应符合硅酸盐水泥、普通硅酸盐水泥（GB175-1999）的要求。3.3.2中细砂 应符合普通混凝土用砂质量标准及检验方法（JG52-92）的要求，含泥量少于3%。3.3.3 界面砂浆的配制 由界面
8、剂、中细砂、高标号水泥按一定比例配制成干粉状，现场加水即可使用。3.3.4聚苯颗粒浆料的配制 先将20-25g水倒入砂浆搅拌机内（加入的水量以满足施工和易性为准），再倒入一袋（25）胶粉料，搅拌5分钟，再倒入一袋（200L）聚苯颗粒继续搅拌10分钟，直至搅拌均匀。该浆料应随搅随用，并且在4小时内用完。3.3.5 抗裂砂浆的使用由我公司采用先进技术生产单组份干粉状材料，现场加水即用，该浆料随搅随用，三小时内用完。4、施工工艺配聚苯颗粒浆料 4.1施工工艺流程用聚苯颗粒浆料抹灰饼、冲筋抹聚苯颗粒浆料、每遍10，直至规定厚度配抗裂砂浆抹第一遍抗裂砂浆粘贴网格布抹第二遍抗裂砂浆4.2施工要点4.2.1
9、基层处理4.2.1.1彻底清除基层墙体表面浮灰、油污、脱模剂、空鼓及风化物等影响墙面施工的物资。墙体表凸起物大于或等于10时应剔除。4.2.1.2各种材料的基层墙体均应涂满界面砂浆。4.2.2保温层准备：保温层厚度为2.5CM，用聚苯颗粒浆料做标准厚度贴饼、冲筋，以控制保温层的厚度。4.2.3保温层施工4.2.3.1聚苯颗粒浆料保温层施工至少两遍。每遍所抹聚苯颗粒浆料厚度不宜超过10，间隔24小时。施工温度偏低时，间隔时间可延长。4.2.3.2聚苯颗粒浆料保温层施工宜自上而下。4.2.3.3最后一遍聚苯颗粒浆料施工时应达到贴饼、冲筋的厚度，并用大杠搓平，使墙面平整度达到要求。4.2.3.4保温
10、层固化干燥（一般3-7天）后，方可进行下一道工序施工。4.2.4 抗裂层施工保温层干燥后，抹第一遍抗裂砂浆，厚度控制在2-3。待抗裂砂浆基本硬化（24小时）后，根据结构尺寸裁剪玻纤网，分段进行铺贴。裁剪过程中不得将网格布形成死折，铺贴过程中不得形成网兜，网张开后应顺方向依次平整铺贴，网与网之间的搭接长度应大于40。网格布铺贴完毕经检查合格后抹第二遍抗裂砂浆，并将网包覆于抗裂砂浆中，使抗裂砂浆的总厚度控制在51，抗裂砂浆面层必须平整。5、质量检验5.1保证项目5.1.1 本系统使用的所有材料质量和技术性能均满足有关国家标准、行业标准陕2005J21及本图集的要求。5.1.2 保温层的厚度构造做法
11、应符合建筑节能设计要求，保温层厚度应均匀，不允许有负偏差。5.1.3 保温层与基层墙体以及各构造层间必须粘结牢固，无脱层、空鼓、裂缝。5.2基本项目5.2.1 表面平整、洁净、接茬平整，无明显抹纹，线角应顺直、清晰，面层无粉化、起皮、爆灰等现象。 5.2.2 墙面埋设暗线、管道后，墙面用网格布和抗裂砂浆加强，表面抹灰平整。 5.2.3 滴水线流水坡方正确且应顺直。5.3 允许偏差和检验方法聚苯颗粒浆料外保温面砖系统允许偏差和检验方法应符合下表：项 目允许偏差检验方法表面平整4用2米靠尺及塞尺检查阴阳角垂直4用2米托线板检查阴阳角方正4用2米靠尺及塞尺检查立面总高度垂直度H/1000且20用吊线
12、检查上下窗口左右偏移20用吊线检查同层窗口上、下20用吊线检查保温层厚度不允许有负偏差用探针、钢尺检查 6、成品保护6.1 门窗框、管道等上的残存砂浆应及时清理干净。6.2 翻架子或升降吊篮时应有防止对已抹好墙面、门窗、洞口、边角、垛等造成破坏的保护措施，其它工种作业时不应污染和损坏墙面，严禁踩踏窗口。6.3保温层、防护层、装饰层在硬化前应防止水冲、撞击、振动。 陕西卓翼节能材料工程有限公司 2014年3月28日Opinions and suggestions on the partys mass line educational practiceAccording to the centra
13、l and provincial, municipal unified deployment, according to municipal Party committee about carrying out the partys mass line educational practice activity in the citys implementation opinions, the spirit of the partys mass line educational practice activities from 20* in January to 99 months, carr
14、ied out at all levels of departments and directly affiliated institutions and grass-roots party organizations. According to my actual County, the county to carry out the education practice put forward the following implementation opinions.First, the overall requirementsCounty county education practi
15、ce to the eighteen Party of eight, the spirit of the the third Plenary Session of the 18th CPC Central Committee as the guidance, conscientiously implement the spirit of general secretary Xi Jinping book series of important speech, earnestly implement the Central Committee really, opinions and advic
16、e , party implementing the guiding ideology of opinions to determine the objectives and requirements, step method, in accordance with the look in the mirror, dress up, wash bath, cure treatment, the general requirements of for the people pragmatic honest people as the theme, in carrying forward the
17、spirit of Zhuanglang Zhuang, improve their work style, service to the masses of the people, the foundation of consolidating grassroots, promote transformation across efforts, to further implement the central eight regulations and The opposition party and government austerity waste regulations , doub
18、le section provincial regulations, municipal provisions of the twelve plan and the implementation measures for on improving the work style of close ties with the masses law, highlight style building, carry out the whole wind spirit, resolutely oppose formalism, bureaucracy, hedonism and wasteful ext
19、ravagance to solve the problems, Party members and cadres of the style and the masses of people strong, the Ministry of Party members and cadres to further improve their thinking and understanding, to further change the style of the wind, the masses to close, honest and pragmatic people honest image
20、 to further establish the foundation to further reinforce the basic level. Style of the building of the new results to promote the construction of a powerful force of the county and the ecological culture of the county and county construction.In educational practice activities of the unit is mainly:
21、 the county and below county departments under the organs, enterprises and institutions directly under the township, street, and community, village, non-public economic organizations, social organizations and other grass-roots organizations. Agencies and branches, each single unit, follow the rules
22、on internal institutions. Educational practice with step by step.To adhere to the county leadership, leadership and leading cadres to focus on outstanding catch to directly contact the service of the masses of law supervision departments and window units, service industry, educational practice, pay
23、attention to grasp the heavy towns, streets and villages, community education activities and the masses of grassroots groups in close contact to strengthen, and the majority of Party members, cadres and the mass line line Marx doctrine view of the masses and the partys education.Always speak serious
24、ly as a basic attitude, adhere to positive education, to carry out criticism and self criticism group, adhere to the pragmatic, more emphasis on leadership, pay more attention to the layers of the demonstration, more focus on the four winds, solve the problem, pay more attention to open the door, th
25、e participation of the masses, pay more attention to the classification guidance. Orderly, pay more attention to the cooperation and cohesion driven, more strict requirements on injection, really supervision practice, ensure education practice is not empty is not empty is not partial, not as a mere
26、formality.Two, the key point of the taskThe main task of the countys education practice is to seize against four wind this focus on centralized solve outstanding problems asked County, township leadership and leading cadres of the four winds, the disadvantages of the style, scale behavior to a large
27、 scale investigation, overhaul, cleaning greatly. At the same time, respond to the concerns of the masses, safeguard the interests of the masses, pay attention to solve practical problems, solve the people around the unwholesome tendencies especially on eat, take the card, Yong lazy luxury, extravag
28、ance and waste fees, privileges and other issues, timely and effective, without any discount to solve, to improve the style of real implementation of the requirements of real to the grassroots, real let group Benefit the public.(a) focus on solving the four winds outstanding issuesThe central and pr
29、ovincial requirements, the county leadership and leading cadres of key performance concept is not correct, do not dare to play, to engage in image project, political project, a leadership guide, a set of ideas, orders and prohibitions, and a policy, there are countermeasures county. The units direct
30、ly under the heavy focus on solving Yung lazy drag, buck passing skin, work is not implemented, the service is not active. The dynamic problem of law enforcement and supervision departments and window units, service industry mainly solve the door hard, ugly face, something difficult, and arbitrary c
31、harges, fines, levies, and breach of privilege, chinakayao, not the problem of law. The township, street The collar of leading bodies and leading cadres to solve key does nottheir own conditions to develop the correct road, the maximum to avoid investment risk, gain profit.(three) vigorously promote
32、 the brand. To establish brand awareness, awareness of the use of brand, brand value, brand acquisition performance, enhance the competitive strength. Concentrated manpower, careful planning, packaging and publicity of a number of unique, market influence and coverage of the brand, the implementatio
33、n of key breakthroughs, to enhance the competitive strength, walking business road the competition of alienation and characteristics, the pursuit of stability and development of the market.(four) to promote the integration of resources. To further broaden their horizons, effective integration of res
34、ources within the group, the city resources, other industries and regional resources, mutual trust, mutual benefit, seeking win-win principle, in the framework of national policies and regulations, strict inspection and argumentation, legal consultation, examination and approval procedures, strict r
35、egulation of economic activities, attract injection the social investment to the industry group, to achieve leveraging the development, ensure that the value of state-owned assets.(five) to strengthen the construction management personnel. Strengthen the management of education and training of cadre
36、s and workers of the existing business, firmly establish the concept of the market, enhance the sense of crisis to adapt to market competition, the sense of urgency, improve the ability to respond to market competition, improve management and operation of the market. At the same time, according to t
37、he need of industrial development, vigorously the introduction of high-quality management management personnel, and strive to build a high-quality professional management team, hard work, and promote the entire workforce knowledge structure, age structure, structure optimization and upgrading abilit
38、y, enhance core competitiveness, adapt to the need of market competition.(six) seriously study the policy for policy. Serious research about social support the development of cultural undertakings in the country and the XX policy, especially the policy of industrial development, financial investment policy, financial policy and tax policy, and actively seek policy, projects and funds, enterprise and industry group mission to promote leapfrog development.11