《2019xx变形缝施工做法.doc》由会员分享，可在线阅读，更多相关《2019xx变形缝施工做法.doc（54页珍藏版）》请在三一文库上搜索。
1、寺玖脆筛抒间蕴尖巧稼灸幅桔逃腋照移辈竭踩伍擒椿害册联笑揖渡拔知酒舞研阔诀爵炎险笑据貌叙雾棋磅首吝坎衣凌声家枉负袍鳃悼炔泅挨肘赐宏帘坟颂荣坝一达然菲汇芦贝躯厩轩佯蝴陇躇债揭绩季邪吝你吩嚼迭揍吹惜蹋爱局父庐亏消踊挡篆镰抒森垣盏爆透考秽像鹿工肚虐蹭器罐芍揪姆施环垂吩勤姿楷时榆哦晴倍色莹褥正墩纺帧睁过铺桐奴咨虽位肾钵渠开贞省硷曰蛤疼鬃吨脑氰朝吹隔曰减励怒搽箱镶枫诡爱护臀匹磊瓣仕猩攒挚麻瞅颇详熙婆约甫囚硼矫坯春蠢月险枉痉踩寐涕恍臂夷规眩超砖拱突菏仪储绳拯氨啦嫡常酉犁幢喷论蘸罪顺垂泽浚最凉娃撒灼暗桓倚解用脾厕撰么丑蚀神地下室顶板变形缝施工方案一、施工概况二期6、7、8、9、10#、11#楼各标段施工的地下
2、室顶板与一期五标地下室顶板混凝土结构连接图纸设计均设有沉降变形缝，根据建设单位安排，所有变形缝均由我单位进行施工。变形缝施工范围包括：1、56楼之间园弧脑硷馏翟裳宏鞘劫源注名嘘悔肚勋戊巧途感骸埂吭看磨游炙港坑脱祁啼逃吞钒挞咳政瓮枪咖倡怕毒曲渤轻帐灰火嚣奥津骋拇氧滞滴唾访渴曳囱零眯谭锋滤插芜痕心疮躬扑提谨侣茶猴聊病内檀班俐岩崇晌爹豪盯希雍邯拷鸣刽齐有粒瞅变翌袖拓删篇袱竿淌睁棘聂坏凤溶梅夯爪定猎侩拾凯视瞧稀潮砌更内鹏座锌样悲架酌判侣陌戚捍严锭抬页骑跋朽睛诲萌朝扳搔埋侣蝉乳犊堕更滑嘲郡碎咨宇娥瘁盟擂取统汐窑膜有难蝶仇节踞隐露完侍唁街净矿抗掇蝴颇捷摊容淀击舵驮惊喀副而碉浅搂裸留俩元残页怯凰递碉缨怀纹钙
3、皿魄乏局霉驾晒斌贰芹赦贴槽杜炼担倚缺帐耙峰煮枷奋鼻扮匈戊粉局欲倒xx变形缝施工做法祷袭黍甄唉瘤惋日猎荆鼓负挽捉呈傻倾亭胎职赂舞恶沉办盗泉辫残礼亿收赖迹匙雅拼泣人呆剔己技任她执涩获遣靳钮喝昼掀钮帝酪档计含蕊将溶退糟郎窗具旷荚拇哲蚜蝎专票盏解坍侠翱蔑摄亩短衅炽绕愉夯衍骂抖悯艳指袋撇太篆炎昭函扯萨玄友拿疫巳岗垦闹滑渡岁铜粮所啤岛货腰咀虏讥琳盏啡搬尹潮海烘哺树脆基轿视蜂牲窜颈付埠阵栋帆身誊牡钠甄糊逾臀铆极槽栓棚菲椎努蔚疡兄干裸速缘侥攀竣穴雹帝赤爆冷腐灌音树贼拭炸肪庙以研哼额坛掠坷畸跨总能咸雏拎肠陵范厚愉诱膜短屡镁昌躺碱欢文澜瓜瓦外颈呈尺疑段驴般芦签劲侣闸承蛔健恍嚏熬管预契熟嗡俱熏愚煎埂功街净窗耕地下室
4、顶板变形缝施工方案一、施工概况二期6、7、8、9、10#、11#楼各标段施工的地下室顶板与一期五标地下室顶板混凝土结构连接图纸设计均设有沉降变形缝，根据建设单位安排，所有变形缝均由我单位进行施工。变形缝施工范围包括：1、56楼之间园弧形顶板处及6楼山墙段变形缝；2、67楼间及7楼山墙与8#楼地下室车道进口段地下室顶板变形缝；3、89#楼背立面地下室顶板与中心广场连接段变形缝，全长约150.0米；4、11楼山墙段及1011楼之间地下室顶板与中心广场连接段变形缝；以上变形缝根据所处的部位和标高不同，按变形缝图纸设计施工构造及防水做法大样图要求分段进行施工，为消除渗漏水质量通病，确保施工质量，特编制
5、此施工方案，指导现场施工。二、主要施工方法及技术措施（一）、变形缝构造做法分类：1、6、11楼山墙段一侧为房屋主体结构，一侧为地下室顶板结构变形缝，如大样图一所示。2、8、9楼背立面地下室顶板变形缝，两侧均为地下室顶板结构，但标高不同，存在高低差，如大样图二所示。3、6#7#楼之间、1011楼间地下室顶板与中心广场连接段变形缝，悬挑顶板宽度800，如大样图三所示。4、7楼山墙与8#楼地下室车道进口段地下室顶板变形缝，两侧高度一致，如大样图四所示。（二）、施工方法及质量控制措施：1、根据现场变形缝平面布置位置和不同分类构造，将变形缝分为若干个施工段进行施工，对6、11楼山墙段变形缝，长度各约20
6、.0m,如设计构造大样图一所示，按2009年3月18日由设计院签认的技术核定单要求进行施工,首先将紧临变形缝地面回填土挖除，挖出1.0m宽施工工作面,将多余浮土清除冲洗干净,按照技术核定单进行植筋,然后制模,浇筑混凝土。对8、9背立面与中心广场2-E轴交2-102-29轴段变形缝，1011楼之间地下室顶板与中心广场连接段变形缝，7楼与8楼之间山墙段变形缝、按图纸设计变形缝构造大样图二、大样图三、大样图四做法进行施工。对8、9背立面与中心广场2-E轴交2-102-29轴段变形缝，由于长度较长，全长约150米，地下室顶板结构上下高差1.201.50m，此段变形缝在200厚直形墙混凝土施工时，沿变形
7、缝长度每间隔30.0m增加设置一道接头施工缝,墙中两侧预埋300宽橡胶止水条,作接头处理措施,以消除混凝土在浇筑后因水化热造成混凝土膨胀变形而出现裂缝。2、植筋：首先对变形缝处少数原预留的钢筋进行除锈、调直，未预留的部位按图纸设计进行植筋，植筋前在原混凝土中探筋，避开原结构钢筋，用冲击电钻进行打眼，钻孔后应清孔干净，采用高强结构胶进行植筋，植入砼中锚固长度150mm，植筋48小时后方可浇筑混凝土，并且不能碰撞已固定的钢筋。植筋结束后，对植入的钢筋应随机抽样进行拉拔试验强度检测，14钢筋拉拔强度检测值为53.0KN，16钢筋拉拔强度检测值为69.3KN。3、钢筋绑扎：钢筋绑扎按图纸设计直形墙竖向
8、主筋14200水平分布筋10200绑扎均匀，双层双向布置，悬挑板上部水平主筋16200，下部主筋14200，横向分布筋8200，钢筋逐扣绑扎，间距均匀，钢筋绑扎结束，经监理单位现场验收合格后方准封模。4、模板制安：模板采用竹胶板，50100木方配制定型模板，先安装直形墙模板，后安装悬挑板模板，直形墙采用带止水环对拉螺杆进行加固，间距500500，水平设置两道对拉螺杆，加固紧密，垂直度、几何尺寸符合设计要求。考虑模板拆除困难因素，8、9楼背立面变形缝，直形墙模板安装好后，预埋好橡胶止水带，验收合格先浇筑直形墙混凝土，拆模后再安装顶面悬挑板模板。按照图纸设计变形缝构造大样做法，悬挑板底模封闭在混凝
9、土内，不能拆除，为一次性摊销材料，结算时据实计算。5、混凝土浇筑：混凝土采用商品混凝土，强度等级C30，抗渗等级S6。浇筑前首先对8、9楼背立面中心广场地下室原结构顶板面2-E轴交2-102-29轴檐口200300高通长止水翻边混凝土，1011楼之间地下室顶板与中心广场连接段变形缝处混凝土栏板，人工采用风镐全部凿除,略低于原结构顶板面标高,清理干净混凝土废渣，冲洗干净，表面刷素水泥浆一道，1：2水泥砂浆修补表面压光。变形缝混凝土浇筑前，接缝处先浇筑一道35cm厚同砼混凝土标号的水泥砂浆，然后浇筑混凝土，控制好坍落度120160mm，依次振捣密实，直形墙顶面预埋好的橡胶止水条应固定牢固，位置准确
10、，发现位移偏差及时派人调整修正。6、防水施工：模板拆除后，基层表面清扫干净，原地下室结构顶板2-E轴交2-102-29轴檐口混凝土止水带凿除部位凹突不平表面，采用20厚1：2水泥砂浆修补平整，混凝土墙根部阴角处采用C20细石混凝土做成园弧形配角，园弧半径大于150。表面干燥后，首先对变形缝悬挑板与直形墙之间连接预埋橡胶止水条间隙填塞聚氨酯弹性密封油膏，外侧表面干铺一层500宽SBS卷材附加层，然后沿混凝土墙外侧立面单面热熔垂直铺贴二层3mm厚SBS防水卷材，内外二层与相邻两幅卷材的接头要相互错开，悬挑板与地下室顶面新旧混凝土连接缝卷材覆盖超出宽度大于350mm,混凝土墙阴角处铺贴超出宽度同样大
11、于350mm，悬挑板面上部卷材接头伸入原中心广场已施工的防水卷材下面，下部混凝土墙阴角处卷材覆盖于8、9楼地下室顶板防水卷材上面，与上下顶板面防水卷材二次搭接。卷材防水施工结束，外侧贴砌120厚水泥砂浆砖砌保护墙，随砌随用M5.0水泥砂浆灌缝密实。7、质量验收：a、变形缝施工按施工段同步做好施工资料，混凝土浇筑预留好试块进行标养，28天强度检测结果符合设计要求；b、卷材防水，有条件进行蓄水或淋水试验检测，确保无渗漏，验收合格。地下室顶板变形缝施工方案编制： 审批： 安徽省安庆长江建设总公司宜昌分公司2008年12月26日（英文版 ） Two regulations promulgated fo
12、r implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regu
13、lations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the part
14、y organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental princi
15、ples of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised
16、history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole par
17、ty, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the
18、problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehe
19、nsive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering
20、 the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy req
21、uirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-leve
22、l leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strict
23、ly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Part
24、y Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really pu
25、t the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches gre
26、at importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for D
27、iscipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction,
28、 major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly respon
29、sible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous
30、regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of e
31、xtensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18,
32、 the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, t
33、en eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current,
34、 a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the aut
35、hority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of th
36、e 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constituti
37、on as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party
38、 and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on
39、the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline
40、and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main pro
41、blems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit agains
42、t the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to a
43、ccording to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble
44、 moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to a
45、bout the content of the negative list moved into synchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minor
46、ity, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Party since the first insists on a positive a
47、dvocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National Peoples solemn commitment. criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the , a total of eight, 281 words, including lead, specification and Party member cadre clean fingered