《ACI-SP-153-1995 VOL-I.pdf》由会员分享，可在线阅读，更多相关《ACI-SP-153-1995 VOL-I.pdf（36页珍藏版）》请在三一文库上搜索。
1、Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 86616
2、3.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 VOL*I 95 0662747 0520955 415 = Fly Ash, Silica Fume, Slag, and Natural Pozzolans in Concrete Proceedings Fifth International Conference Milwaukee, Wisconsin, USA, 1995 Editor V.M. Malhotra Volume 1 SP-153 Copyright American Concret
3、e Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d
4、o c i n .c o m /l i u y x 866 A C 1 SP-153 VOLSI 95 O662949 0520956 351 DISCUSSION of individual papers in this symposium may be submitted in accordance with general requirements of the AC1 Publication Policy to AC1 headquarters at the address given below. Closing date for submission of discussion i
5、s January 1, 1996. All discussion approved by the Technical Activities Committee along with closing remarks by the authors will be published in the May/June 1996 issue of either AC1 Structural Journal or AC1 Materials Journal depending on the subject emphasis of the indi-vidual paper. The Institute
6、is not responsible for the statements or opinions expressed in its publications. Institute publications are not able to, nor intended to, supplant individual training, responsibility, or judgment of the user, or the supplier, of the information presented. The papers in this volume have been reviewed
7、 under Institute publication procedures by individuals expert in the subject areas of the papers. Copyright O 1995 AMERICAN CONCRETE INSTITUTE P.O. Box 19150, Redford Station Detroit, Michigan 48219 AI1 rights reserved including rights of reproduction and use in any form or by any means, including t
8、he making of copies by any photo process, or by any electronic or mechanical device, printed or written or oral, or recording for sound or visual reproduction or for use in any knowledge or retrieval system or device, unless permission in writing is obtained from the copyright proprietors. Printed i
9、n the United States of America Editorial production Victoria Lunick Library of Congress catalog card number 95-76270 Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproductio
10、n or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 V O L X I 95 Ob62949 0520957 298 PREFACE The Canadian Centre for Mineral and Energy Technology (CANMET) of Natural
11、 Resources Canada, Ottawa, has played a significant role in Canada for over twenty-eight years in research on fly ashes, ferrous and nonferrous slags, and silica fumes, in order to conserve both resources and energy. 111 July-August 1983, CANMET, in association with the Ameri- can Concrete Institute
12、 and the U.S. Corps of Engineers, sponsored a five day international conference at Montebello, Quebec, Canada, on the Use of Fly Ash, Silica Fume, Slag and Other Mineral By-products in Concrete. The main purpose of the conference was to bring together representatives from industries, universities, a
13、nd government agencies to present the latest information on these materials and to explore new areas of needed re- search. The two volume proceedings of the conference containing 62 papers from 15 countries were published as AC1 Special Publication SP-79. In 1986, CANMET, in association with the Ame
14、rican Concrete Insti- tute, the Canadian Society for Civil Engineering, and a number of organ- izations in Spain, sponsored the Second International Conference on the subject of Fly Ash, Silica Fume, Slag, and Natural Pozzolans in Concrete. The conference was held April 21-25, 1986, in Madrid, Spain
15、. The two volume proceedings of the conference containing 72 papers from more than 20 countries were published as AC1 Special Publication SP-91. In 1989, CANMET, in association with the American Concrete Iristi- tute, Norwegian Institute of Technology, and several other organizations in Canada and N
16、orway, sponsored the Third International Conference on the above subject. The conference was held June 18-23, 1989, in Trondheim, Norway. The two volume proceedings of the conference containing 83 papers from more than 25 countries were published as AC1 Special Publi- cation SP-114. In 1992, CANMET,
17、 in association with the American Concrete Insti- tute, Electric Power Research Institute, U.S.A., and several other or- ganizations in Canada and Turkey, sponsored the Fourth International Conference on the subject. The conference was held May 3-8, 1992, in Istanbul, Turkey. More than 130 papers fr
18、om 32 countries were received and reviewed in accordance with the policies of the American Concrete Institute; 89 papers were accepted for publication as AC1 Special Publi- cation SP-132. In 1995, CANMET, in association with the American Concrete Insti- tute, Electric Power Research Institute, U.S.A
19、., Canadian Electrical iii Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信
20、或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 V O L X I 95 m Ob62949 0520958 124 m Association, Montreal, and several other organizations in Canada and the United States, sponsored the Fifth International Conference on the subject. The conference was
21、 held June 4-9,1995, in Milwaukee, U.S.A. The two vol- ume proceedings of the conference containing 62 papers Com 23 countries were published as AC1 Special Publication SP-153. To all those whose submissions could not be included in the confer- ence volumes, the Institute and the Conference Organizi
22、ng Committee ex- tend their appreciation for their interest and hard work. The accepted papers have been published in two volumes. The first volume contains papers dealing with fly ash and natural pozzolans, and the second volume consists of papers dealing with silica fume, slag, and other materials
23、. Some papers could have been published in either volume because the material covered more than one subject. In addition to the papers which have been published in these vol- umes, more than 20 other papers were presented. Most of these papers were published as supplementary papers, and the authors
24、have been encouraged to publish them in technical journals of their choice. Thanks are extended to the members of the “Paper Review Panel“ which met as Cascais, Portugal, June 5-9, 1994, to review the papers. Without their dedicated effort it would not have been possible to publish these volumes bef
25、ore the conference. The cooperation of the authors in accepting reviewers suggestions and revising their manuscripts accordingly is greatly appreciated. The help and assistance of Mr. H. S. Wilson, Consultant, Ottawa, Gordon D. Brearly and Maria Venturino of CANMET are gratefully ac- knowledged in t
26、he administrative work associated with the conference, and in processing of the manuscripts both for AC1 proceedings and the supple- mentary volume. Thanks are also extended to A. Bilodeau (Chairman) and Messrs. B. Fournier and R. Chevrier (Members) of the Slide Review Panel for their services to en
27、sure that the slides meet the CANMET/ACI cri- terion. As an integral part of the conference, a special symposium to honor Dr. Narayan Swamy, Prof. Dept of Civil Engineering, University of Shef- field, U.K., was held during the conference. The papers presented at this symposium have been published in
28、 a separate volume. V. M. Malhotra, Editor Chairman, CANMET/ACI Fifth International Conference on Fly Ash, Silica Fume, Slag and Natural Pozzolans in Concrete June 1995 iv Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Berni
29、e Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-1-53 V O L X I 95 W Obb2949 0520959 Ob0 m Organizing Committee
30、Fifth International Conference on Fly Ash, Silica Fume, Slag and Natural Pozzolans in Concrete Milwaukee, Wisconsin 1995 V. M. Malhotra Chairman H. S. Wilson Secretary-Treasurer Members T. W. Bremner H. L. Isabelle W. S. Langley V. S. Ramachandran Dedicated to Members of the “Paper Review Panel“ who
31、 assisted in the review of the manuscripts. V Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过
32、20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 V O L X I 95 H 0662949 0520760 882 = CON TENTS . PREFACE . 111 PROPERTIES OF HIGH-VOLUME FLY ASH CONCRETE MADE WITH HIGH-EARLY STRENGTH ASTM TYPE III CEMENT by A. Bilodeau and V. M. Mal
33、hotra . 1 STRUCTURAL CONCRETE INCORPORATING HIGH VOLUME OF FLY ASH by D. Galeota, M. M. Giammatteo, and R. Marino 25 USING MEDIUM- TO HIGH-VOLUME FLY ASH BLENDED CEMENTS TO IMPROVE THE SULFATE RESISTANCE OF HIGH-LIME FLY ASH CONCRETE by J. R. Prusinski and R. L. Carrasquillo 43 PROCESSED FLY ASH FOR
34、 HIGH PERFORMANCE CONCRETE by H. A. W. Cornelissen, R. E. Hellewaard, and J. L. J. Vissers . 67 EFFECT OF FLY ASH COMPOSITION ON THERMAL CRACKING IN CONCRETE by M. D. A. Thomas, P. K. Mukherjee, J. A. Sato, and M. F. Everitt . 81 A MODEL FOR PREDICTING THE COMPRESSIVE STRENGTH OF STRUCTURAL FLY ASH
35、CONCRETE by F. de Larrard 99 LONG-TERM PERFORMANCE OF GROUT CONTAINING FLY ASH AND BRINE by A. A. Al-Manaseer and M. D. Haug . 109 Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDT
36、No reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 VOLSI 95 O662949 0520963 719 PROPERTIES OF MORTAR MIXTURES CONTAINING HIGH AMOUNTS OF VARIOUS SUPPLE
37、MENTARY CEMENTITIOUS MATERIALS by C. Talbot, M. Pigeon, J. Marchand, and H. Hornain . 125 PRODUCTION OF SULFATE-RESISTANT CONCRETE CONTAINING HIGH-CALCIUM FLY ASH AND SODIUM SULFATE ADMIXTURE by R. B. Freeman and R. L. Carrasquillo 153 INFLUENCE OF PARTICLE SIZE DISTRIBUTION ON THE EFFECTIVENESS OF
38、TYPE-F FLY ASH IN SUPPRESSING EXPANSION DUE TO ALKALI-SILICA REACTIVITY by M. A. Brub, A. Carles-Gibergues, J. Duchesne, and P. Naproux 177 EXPANSIVE CEMENT PRODUCED FROM AFBC ASH BY ALKALI SULPHATE ACTIVATION APPROACH by W. Jiang and D. M. Roy. . 193 ACTIVE B - q S CEMENT FROM FLY ASH AND KILN DUST
39、 by A. Xu and S. L. Sarkar . 213 THE INFLUENCE OF HIGH EARLY STRENGTH (HES) MINERALIZED CLINKER ON THE STRENGTH DEVELOPMENT OF BLENDED CEMENTS CONTAINING FLY ASH, SLAG OR GROUND LIMESTONE by S. Kelham, J. S. Damtoft, and B. L. O. Talling 229 MIXTURE PROPORTIONING FOR HIGHLY-FLOWABLE CONCRETE INCORPO
40、RATING LIMESTONE POWDER by K. Sakata, T. Ayano, and A. Ogawa . 249 PROPERTIES OF LIGHTWEIGHT AGGREGATE PRODUCED FROM A HIGH CALCIUM FLY ASH by G. Baykal, T. zturan, M. Savas, and K. Z. Ramadan 269 FIVE-YEAR EXPOSURE TEST ON LONG-TERM PROPERTIES OF CONCRETES CONTAINING FLY ASH, BLAST-FURNACE SLAG AND
41、 SILICA FUME by T. Sasatani, K. Torii, and M. Kawamura 283 MOVEMENT OF IONS THROUGH MORTAR MIXED WITH MINERAL ADMIXTURES by N. Otsuki, S. Nagataki, and M. Hisada . 297 viii Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bern
42、ie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without license from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 V O L X I 75 m 0662749 0520962 655 m PROPERTIES OF CONCRET
43、E WITH BAGASSE ASH AS FINE AGGREGATE by B. K. Baguant . 315 MECHANICAL TREATMENT OF FLY ASHES: STRENGTH DEVELOPMENT AND WORKABILITY OF MORTARS CONTAINING GROUND FLY ASHES by J. Monz, J. Pay compressive strength, drying shrinkage; flexural strength; flv ash; freeze thaw durability; hieh earlv-strengt
44、h cements; modulus of elasticity; splitting tensile strength; superplasticizer 1 Copyright American Concrete Institute Provided by IHS under license with ACI Licensee=IHS Employees/1111111001, User=Wing, Bernie Not for Resale, 03/19/2007 03:57:25 MDTNo reproduction or networking permitted without li
45、cense from IHS -,-,- 本文件原文共500余页，超过20M，无法上传。 如有需要请发站内信或e m a i l ：l i u y x 866163.c o m 联系人：草庐一苇：w w w .d o c i n .c o m /l i u y x 866 A C 1 SP-153 V O L I I 95 W Obb2949 0520965 364 w 2 Bilodeau and Malhotra AC1 member Alain Bilodeau is a concrete research engineer, Advanced Concrete Technology P
46、rogram, CANMET. His current research interests are primarily in the areas of the use of supplementary cementing materials and durability of concrete. He has published several papers on concrete technology and is a member of the CSA Committee on Concrete Materials and Construction. AC1 honorary membe
47、r V. Mohan Malhotra is Program Principal, Advanced Concrete Technology Program, CANMET. He is a former member of the AC1 Board of Direction and has served on numerous AC1 and ASTM committees. He is a prolific author, editor, and researcher, and has received many awards and honors from AC1 and other
48、institutions throughout the world. INTRODUCTION In 1990, CANMET undertook a project to develop data base on high- volume fly ash concrete incorporating selected fly ashes and cements from the U.S.A. This investigation was performed for the Electric Power Research Institute (EPRI), Palo Alto, California, under a subcontract with Radian Canada Inc., Mississauga, Ontario. Eight fly ashes, covering a wide range of chemical compositions, and two ASTM Type I portland cements from two differe